________________________________________________________________________________
Ford 1520 Tractor Problems
Recently I got a failure with my Ford 1520 front end loader. Diesel
engine can not crank over. Explain me what kind of failure?
Wrong type or grade of fuel used. The injection pump is broken. Inspect
and refit. Timing of fuel injection pump is incorrect. Adjust if needed.
1520 tractor damages. Engine has low power or compression. How should I
troubleshoot it?
There is no full fuel feed due to misalignment of fuel pump control
rods. Adjust control rods.
Help anybody what is damage if diesel engine stops suddenly?
Air in fuel system. Bleed air from system. Fuel tank vent restricted.
1520 tractor trouble. Hard shifting transmission. What's the reason?
Linkage needs lubricant - Lubricate. Shift cover loose - Tighten cover.
Please give me information why my steering wheel rotates without
resistance? What should I do for troubleshooting?
Low oil index - Fill the tank. Steering cylinder has a defect - Change
the seal. Defect in the power steering pump - Repair pump.
I got a Ford 1520 with loader in march. Currently there is damage.
Diesel not starting. Can anybody help me identify the cause of
breakdown?
Starter turns bad - Check starter and replace if necessary. Restriction
in a fuel pipe - Clean and wash. Dirty fuel filter element - Install new
filter. Wear piston rings - Install new piston rings.
I bought the same model. Recently, steering wheel works very badly. Help
me find out what's issue?
The minimum oil level. Tight spindles.Different from tyre inflation -
Inflate both tyres to same specified pressure. Leak in hydraulic
connections. It is necessary to eliminate the problem. Pump of power
steering is broke. Install the new pump. Hydraulic power steering is
defective. Diagnose the power steering.
Ford 1520 tractor problem. Diesel motor hard starting. Need help to
identify the source of damage. What can I do?
Choke cable not adjusted properly. Choke not operating properly.
Incorrect functions of the cold start system. Damage or wear of piston
rings. Defective fuel pump drive shaft. Water, dirt, or air in fuel
system. Drain, flush, fill and bleed system. Crankcase oil too heavy.
Use oil of proper viscosity.
1520 tractor diesel failures. Diesel starts hard sometimes. How can i
resolve an issue?
Restricted Fuel Lines. Air in fuel system. Exhaust pipe is clogged. Slow
starter speed. Diesel injection nozzles faulty or sticking. Filter
clogged. Incorrect timing.
Steering not working on my tractor. What is problem?
The hydraulic system has air. We recommend you release air from system.
The minimum oil level in system. Fill the tank. Steering hydraulic
cylinder worn out Replace the faulty part.
I am working on the exact same tractor. Why diesel doesn't start? How
could i fix malfunction?
Valve timing is improper - Set a valve timing. Bad cylinder compression.
Worn cylinder bores - Repair it. Leakage between valves and seats -
Eliminate leak.
Ford 1520 malfunctions. This is a diesel motor knock. what kind of
issue?
This is a small residue of engine oil. Add oil. Low engine speed. Oil
level low.
I can't find the reason why front axle to howls regularly when driving?
This is the failure of any gear. You must change the gears. Roller
bearings are very worn out. Replace it.
I'm the owner this tractor about four years. Regularly engine start is
intermittent. What you need to fix?
Injector has clog. Need to check injector. Injection pump is not
working. Install a new high-pressure fuel pump.
I bought the exact same tractor. Can anybody tell me what's problem if
differential lock breaks down suddenly? How to solve the problem?
Diaphragm damaged or discs friction clutch worn out. Change worn
components.
Our company has Ford 1520 front end loader. Diesel engine does not
start. Help me what's issue?
Most likely fuel filter element has dirt. Or high-pressure fuel pump to
lost adjustments.
Need help. Diesel overheats regularly. What kind of malfunction?
Low coolant level. Fill radiator to proper level, check radiator,
coolant recovery tank, and hoses for loose connection or leaks. Clogged
radiator - Clean the core. Engine overloaded. Shift to lower gear or
reduce load. Loose or problem fan belt. Adjust belt tension.
My friend has Ford 1520 with loader. Today he got a crunch in the rear
axle. Which part is damaged?
These signs talk about destruction of bearings.
Help with the question what is fault if diesel excessive white smoke at
idle?
If white smoke visible from the exhaust pipe you must to replace piston
rings immediately. Deficient compression - Adjust top clearance.
________________________________________________________________________________
________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
FORD TRACTORS SPECIFICATIONS |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
FORD FRONT END LOADERS SPECIFICATIONS |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
FORD TRACTORS TROUBLESHOOTING | ||||
1710 | 1900 | 2120 | 2600 | 3600 |
3930 | 4100 | 4630 | 5600 | 5640 |
6410 | 6610 | 6640 | 6710 | 6810 |
7610 | 7740 | 7810 | 8210 | 8240 |
8630 | 8830 | 8770 | TW30 | TW35 |