________________________________________________________________________________
John Deere D170 Problems
John Deere D170 Engine Troubleshooting
Engine will not start
Fuel tank is empty - Add gasoline.
Wrong grade of gasoline - Change gasoline.
Old gas - Drain fuel and add fresh.
Water or air in fuel system - Remove air or water from system.
Faulty spark plug wire - Check the spark plug wires.
Faulty spark plug - Test ignition spark.
Clogged fuel filter - Replace fuel filter.
Faulty safety switch - Change damaged switch.
Carburetor is not working properly - Inspect and adjust.
Inspect starter cranking speed RPM. Compression problems.
Gas engine is difficult to start
Spark plug wear - Inspect the spark, replace if necessary.
Carburetor incorrectly set - Set carb correctly.
Dirt in fuel pipes - Clean fuel system components.
Throttle cable worn - Install new throttle cable.
Stale or incorrect gasoline - Pour quality gasoline.
Loose or corroded electrical connections - Checking and replace.
Starter problems - Check the starter and replace defective components.
Engine stalling, surging or running rough
Cooling fins plugged - Remove dirt from cooling fins.
Loose electrical connections - Check and restore defective connections.
Incorrect ignition settings - Check ignition and adjust if necessary.
Throttle cable sticking - Check and change if required.
Air filter blocked - Clean or change air filter.
Engine misses
Spark plug wear - Replace spark plug.
Carburetor problems - Test and repair.
Ignition coil is damaged - Inspect ignition coil and change if required.
Engine overheating
Excessive engine load - Reduce loads.
Air intake screen blocked - Clean and wash dirty components.
Engine oil low or too high - Checking oil level and oil pressure.
Incorrect engine oil viscosity - Change engine oil.
Check internal bearing clearance.
Too Fast idle - Adjust fast idle.
Engine doesn't idle speed
Poor spark plug contact - Check spark plug gap.
Faulty spark plug - Check the spark and change defective spark.
JD D170 Engine knocks
Stale gasoline - Use correct gasoline.
Engine overloaded - Reduce loads.
Oil level low - Add to required level.
Engine speed too low - Adjust carburetor.
Piston rings and cylinder bore are wear - Replace defective components.
Inspect for engine overheats from clogged cooling fins.
Checking and adjusting valve clearance.
Inspect for loose or wear connecting rods.
Engine backfires
Check spark plug and replace if necessary.
Adjust or change the throttle.
Check and adjust carburetor.
Check and adjust ignition coil air gap.
Check for sticking valves.
Checking and adjusting valve clearance.
Inspecting flywheel key.
Engine loses power
Engine overheating - Check air cleaner for plugged condition.
Excess engine oil - Excess oil needs to be drained.
Fuel pump is damage - Inspect and repair fuel pump.
Governor is damage - Inspect and repair governor.
Check carburetor float adjustment.
Checking engine compression.
Engine using too much gasoline
Insufficient throttle opening - Replace throttle cable.
Incorrect carburetor adjustment - Checking and adjusting carburetor.
Black exhaust smoke
Air filter element clogged - Check and clean.
Choke not fully engaged - Check and repair throttle.
Checking and adjusting carburetor float level.
John Deere D170 Electrical System
Troubleshooting
Starter does not run
Fuse is defective - Check and replace.
Battery terminals are corroded - Clean contacts.
Battery is discharged - Battery charging required.
Ignition switch defective - Change the lock.
Starter is damaged - Install new starter.
Wires disconnected - Reconnect wires.
Battery doesn't charge
Battery cells defective - Replace the battery.
Battery terminals and cables are dirty - Clean or replace cable.
Lighting does not function
Light plug disconnected.
lamp defective.
Wiring short circuit.
JD D170 Machine Problems
Excessive tractor vibration
Equipment drive belts worn out - Inspect and change damaged belt.
Traction drive belt damage - Check and replace belt.
Drive pulley is dirty - if required.
Cutting blade loose or unbalanced - Tighten and balance blade.
Engine runs but tractor won't move
Parking brake locked - Unlock park brake.
Bypass valve lever is engaged - Deactivate the bypass valve.
Mower blade could be loose - Fasten the blades securely.
Poor blade balancing - Balance the blades correctly.
Too little transmission oil - Topping up oil.
John Deere D170 Mower Deck Troubleshooting
Plugged discharge chute
Travel speed too fast - Use slower speed.
Grass too long - Adjusting cutting height.
The grass is wet - Don't mow while wet grass.
Low engine speeds - Open choke wide.
Loss of airflow - Check engine speed.
Mower cuts too low - Adjust to higher cutting.
Incorrect belt installation - Install the belt correctly.
Lawn mower leaving uncut grass
Mower deck clogged - Clean mower deck.
Blade wornout - Inspect and fit new blade if required.
Deck level is too low - Leveling the mower deck.
Grass bag too full - Clean bagger.
Travel speed too fast - Need to reduce speed.
Slipping drive belt
Dirt in the sheaves - Check and clean.
Drive belt wear - Install new belt.
Poor belt tension - Belt tension needs to be adjusted.
Excessive mower vibration
Debris in sheaves or on mower deck - Remove debris from deck or pulley.
Pulley or belt faulty - Replace damaged parts.
Pulley or belt out of alignment - Check and align.
Incorrect blade balancing - Blades need balancing.
Blade strips grass
Cutting height too low - Check and adjust height.
Mower rollers not adjusted improperly - Adjust front or back wheel
height.
Tire pressure is uneven - Inflate tires as required.
Faster mower blade speeds - Adjust the speed of blades.
Bent blades during operation - Replace blades.
Uneven Cut
Mower deck not leveled properly - Deck leveling required.
Low tire inflation - Increase tire pressure.
Incorrect rollers height - Check the rollers heights.
Traveling too fast - Need to reduce speed.
Mower blades blunt - Sharpen the blade or install a new one.
________________________________________________________________________________
- ALL JD MODELS
- John Deere D125 Troubleshooting
- John Deere D130 Troubleshooting
- John Deere D140 Troubleshooting
- John Deere D160 Troubleshooting
________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
JOHN DEERE LAWN TRACTORS SPECIFICATIONS |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
ENGINES FOR JOHN DEERE LAWN TRACTORS |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
JOHN DEERE TRACTORS ATTACHMENTS | ||||
420 | 430 | 455 | 790 | 990 |
X300 | X320 | X330 | X350 | X475 |
X485 | X500 | X540 | X570 | X590 |
X700 | X720 | X738 | X758 | 1023E |
2025R | 2210 | 2520 | 3025E | 3032E |
3038E | 3038R | 3039R | 3046R | 3203 |
3320 | 3520 | 4052R | 4066R | 4100 |
4105 | 4115 | 4200 | 4310 | 4320 |
4400 | 4410 | 4520 | 4600 | 4720 |
________________________________________________________________________________________
JOHN DEERE FRONT END LOADERS |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
JD TRACTORS TROUBLESHOOTING | ||||
2640 | 3040 | 3310 | 3650 | 4100 |
5050D | 5090R | 5410 | 6105R | 7200R |
E130 | L111 | LA110 | LT155 | X300R |
________________________________________________________________________________________
JOHN DEERE FARM TRACTORS SPECIFICATIONS |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________