________________________________________________________________________________
Kubota L5030 - Problems and Solutions
The day before I got the problem with my Kubota L5030 HST. Motor can not
crank over. Explain me what is the probable breakdown?
You used an incorrect type of fuel. Fuel pump not working. Inspect and
replace. Incorrect fuel injection pump timing. Need to set up.
L5030 tractor breakdowns. Low engine power. How should I get rid of
problem?
Compression leak - Replace head gasket, tighten cylinder head screw,
glow plug and nozzle holder. Engine not broken-in.
Can someone say me what is damage if diesel engine stops suddenly?
Governor, plunger or sliding disc sleeve seized. Check, repair or
replace them.
L5030 tractor failure. Transmission shifts hard in reverse. What's the
reason?
Wrong transmission lubricant - Drain and fill with recommended
lubricant.
I would like to know why steering wheel spinning without opposition?
What do I need to do to fix an issue?
The minimum oil level - It is required to top up the oil. Steering
cylinder has a defect - Perform repair. Defect in the power steering
pump - Repair pump.
I purchased a Kubota L5030 HST in september. Today there is breakdown.
Diesel will not start. Can anyone help me define a source of trouble?
Starter speed is slow - Diagnose starter and reinstall if necessary.
Fuel pipes are contaminated - You should make washing and cleaning.
Filter element is dirty - Change the filter. Piston ring failure -
Change piston rings.
I bought the same model. Recently I noticed the steering stopped
working. Tell me what is problem?
Minimum Oil Rating. Air bubbles in hydraulic system. Bleed air out of
the system. Check the suction pipe and rectify any leakage. Oil flows
out of the system. Eliminate the problem. Pump of power steering is
broke. Replace the pump. Power steering defective. Install the new power
steering.
L5030 tractor trouble. Diesel motor cranks but not starting. Help me
specify the source of damage. What needs to be repaired?
Loose or damaged wiring. Check all wiring. Weak or dead battery. Cold
start system worked incorrectly. Broken or Worn Piston Rings. Valve
Leakage/Adjustment Bad. Water mixed in the fuel. Crankcase oil too
heavy. Use oil of proper viscosity.
Kubota L5030 diesel breakdowns. Diesel engine is difficult to start
sometimes. How do i fix it?
Restricted Fuel Lines. Air leaks on suction lines. Exhaust pipe is
clogged. Slow starter speed. Diesel injection nozzles faulty or
sticking. Filter clogged. Incorrect timing.
There was a breakdown of the steering on our tractor. What is problem?
The air is in hydraulic system. You should draw out air. Oil low level
in the tank. Top up the oil. Steering cylinder has a defect Change the
seal.
I have the same tractor. Why motor doesn't start? How could i fix
malfunction?
Incorrect valve timing - Adjust valve timing. Low compression. Cylinder
bores wear - Repair it. Leakage between seats and valves - Remove leaks.
L5030 tractor damages. I hear the engine knocking. what kind of trouble?
This is a small residue of engine oil. Add oil. Engine out of time.
Excessive engine load.
Please help to understand why driving front axle produces a rumble
continuously during operation?
Gears teeth crumbling. You need to install new gears. Roller bearings
are firmly erased. Fit new bearings.
I'm the owner this tractor less than five years. Often motor start is
intermittent. What a breakdown?
Injector is clogged. You must to check a nozzle. Injection pump is
damaged. Install a new injection pump.
I have the same tractor. Answer my question what reason if differential
lock can break suddenly? What's solution to the problem?
This is the diaphragm rupture or replace friction clutch discs. Change
worn components.
I'm using Kubota L5030 HST. Diesel engine doesn’t want to work. I need
to know how can I fix this?
Most likely Dirt in the fuel system. Otherwise the fuel pump adjustment
is not correct.
Need help. Engine overheating occurs. How to repair it?
Little coolant in the cooling system. You need to fill the system. Clean
the radiator from dirt and dust, if necessary, clean cooling system from
scale. Adjust the fan belt tension. Detect the faulty injectors, wash,
clean and adjust them. Motor overloaded - Reduce motor load. Fan belt is
damaged. Change as required.
My dad uses Kubota L5030 HST. Three days ago he got knocking in the
crankcase of the drive axle. What's wrong?
These sounds evidence of damaged bearings.
Can someone say me what is fault if engine emits white smoke?
If white smoke appeared from exhaust pipe you must to replace piston
rings urgently. Insufficient fuel delivery. Shortage of or faulty fuel.
________________________________________________________________________________
________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________