________________________________________________________________________________
Kubota M5400 Problems
Recently I got some trouble with my M5400 tractor. Diesel engine can not
rotate. Tell me please what is the trouble?
You must use the recommended fuel grade. High-pressure fuel pump is
damaged. Diagnose and change. Incorrect fuel pump timing. Adjustment
required.
Kubota M5400 issue. Loss of power. How should I correct the situation?
Fuel filter, fuel prefilter, water separator or fuel line clogged -
Replace fuel filter unit. Clean fuel prefilter, water separator, fuel
line.
Help anybody what is damage if diesel engine runs irregularly?
Air in the fuel lines or filter element blocked. Check, bleed air or
replace the filter element.
M5400 tractor issue. Transmission shifts hard. What could it be?
Transmission misaligned - Correct alignment.
Please give me information why my steering wheel turns too easy? How do
I act to fix an issue?
Low Oil Rating - Top up the oil. Steering cylinder has damage - Perform
repair. Steering pump have worn - Repair pump.
I purchased a Kubota M5400 in september. Now there is failure. Diesel
will not start. Can anyone help me find the source of damage?
Starter failure - Change or refit. Dirt in the fuel system - Clean and
flush. Dirty fuel filter element - Replace fuel filter. Piston ring
failure - Refit a new set of piston rings.
I have the same model. Yesterday I saw steering wheel turns very badly.
Tell me what's malfunction?
Minimum Oil Rating. Air in steering hydraulic system. Air-bleed steering
system. Bent spindle arm. Leak in hydraulic connections. It is necessary
to eliminate a defect. Pump of power steering is broke. Repair the pump.
Power steering has a defect. Diagnose the power steering.
M5400 tractor issue. Diesel cranks but will not start. Need help to
determine the cause of damage. What needs to be repaired?
High-speed and idle mixture needles not properly adjusted. Cold start
system used incorrectly. Piston rings are wear or deformed. Broken Fuel
Pump Drive Shaft. Water mixed in the fuel. Fuel too heavy at low
temperature.
Kubota M5400 diesel issues. Motor hard to start permanently. How can i
resolve the question?
Restricted Fuel Lines. Air in fuel tank. Bleed fuel tank. Exhaust pipe
is clogged. Slow starter speed. Injection fuel is little or the spray is
not excellent. Filter clogged. Long Idle periods.
Steering does not operate on my tractor. What repairs should I do?
Hydraulic system has a large amount of air. You should draw out air.
Hydraulic oil low level in the tank. Top up the oil. Steering cylinder
has a defect Replace the faulty part.
I have the same tractor. Why motor failure to start? How could i resolve
an issue?
Valve timing is incorrect - Make adjustment. Bad cylinder compression.
Cylinder bores are worn - Need overhaul. Leakage between valves and
seats - Eliminate leak.
Kubota M5400 troubles. Diesel knocks. what is the breakdown?
Oil of small quantity. You should pour this. Coolant temperature
dropped.
I have a problem why driving front axle to howls regularly while
driving?
Gears teeth crumbling. Replace gears. ball bearings crumbled. Fit new
bearings.
I'm the owner this tractor about four years. Recently, motor start is
difficult. How to eliminate?
Nozzle is clogged. Need to inspect a nozzle. Injection pump has a
breakdown. Requires replacement of high-pressure fuel pump.
I get the same tractor. Can anybody tell me what reason if differential
lock assembly is defective swiftly? What's solution to the problem?
Diaphragm damaged or replace friction clutch discs. Change worn
components.
We have Kubota M5400. Diesel engine doesn’t want to work. Tell me what
is problem?
Possibly fuel filter element has dirt. Otherwise injection pump to lost
adjustments.
Need help. Engine overheating occurs. What is the problem?
Lack of coolant in cooling system - Fill cooling system to proper level.
Defective thermostat - Replace. Dirty, plugged, or damaged shrouding or
engine fins. Insufficient engine oil - Inspect oil level and replenish
if necessary. Motor overloaded - Reduce motor load. Loose or defective
fan belt - Replace fan belt as required. Check belt tensioner.
My friend has M5400 tractor. Two days ago he heard a crunch in the rear
axle. What is the malfunction?
These symptoms point to damaged bearings.
Tell me why engine excessive white smoke at idle?
If white gas comes out of exhaust pipe you required to change piston
rings immediately. Excessive engine oil - Reduce to specified level.
________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
KUBOTA TRACTORS SPECIFICATIONS |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
KUBOTA ENGINES DATA AND SERVICE SPECS |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
KUBOTA FRONT END LOADERS |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
KUBOTA TRACTORS TROUBLESHOOTING | ||||
L235 | L2501 | L2550 | L275 | L3110 |
L3301 | L35 | L3710 | L3901 | L4310 |
L5030 | M4700 | M5700 | M6040 | M6800 |
M8200 | M8540 | M9000 | MX5100 | MX5200 |