________________________________________________________________________________

Massey Ferguson 5475 Troubleshooting methods

The other day I recognized trouble on my MF 5475. Diesel will not crank. Tell me please what is the damage?

Fuel type is wrong. Fuel pump drive problems. Inspect and refit. Wrong fuel injection pump timing. Adjust as required.

Massey Ferguson 5475 breakdowns. Reduced performance of the engine. How can I troubleshoot it?

Blocked air filter. Clean it or replace it if necessary. Dirty engine air screen/fins. Clean engine air screen/fins.

Help with the question what is defect if diesel engine misses?

Engine overheating. Defective injection nozzle. Loose electrical connections.

5475 model failure. Transmission rough shifting. What's fault?

Differential bevel gears worn or damaged. Shifting gears while tractor is in motion.

Somebody help me why my steering wheel spinning too easy? What are my actions to troubleshoot?

The minimum oil level - Top up the oil. Steering cylinder has damage - Make a replacement. Defect in the power steering pump - Install a new pump.

I bought MF 5475 in april. Nowadays there is malfunction. Diesel motor not starting. Can anyone help me diagnose the cause of failure?

Starter faulty - Replace or repair. Clogging in the fuel line - Wash and clean the fuel line. There is dirt in the fuel filter - Renstall filter element. Worn piston rings - Refit a new set of piston rings.

I use the same tractor. Recently I noticed the steering stopped working. Can anybody tell me what is problem?

The minimum oil level. It is required to top up the oil. Oil flows out of the system. It is necessary to eliminate a defect. Steering pump is worn out. Install the new pump. Wear of power steering. Requires repair.

5475 model failure. Motor is difficult to start. Please help me determine the source of failure. What should I check?

Air filter element restricted. Air lock in fuel line. Restricted fuel tank vent. Stale fuel. Cold start system worked incorrectly. Defect or failure of piston rings. Valve Leakage/Adjustment Bad. Water, dirt, or air in fuel system. Drain, flush, fill and bleed system. Fuel too heavy at low temperature.

Massey Ferguson 5475 diesel damages. Diesel is difficult to start permanently. How can i resolve the question?

Restricted Fuel Lines. Air leaks on suction lines. Clogging in exhaust pipe. Low voltage - Charge battery. Diesel injection nozzles faulty or sticking. Clogged fuel filter. Clean or replace fuel filter. Long Idle periods.

There was a breakdown of the steering on our tractor. What's a breakdown?

The air is in hydraulic system. You should remove air. Hydraulic oil low level in the tank. Top up the oil. Steering cylinder has a defect Make a replacement.

I use the same tractor. Why diesel has not been started? How can i resolve the question?

Valve timing is incorrect - Need setting of valve timing. Low compression. Cylinder bores wear - Need overhaul. Leaks between valves and seats - Need Removal of leakage.

5475 tractor issue. I hear a diesel knock. what is the probable problem?

This is a small residue of engine oil. Fill up. Engine overheated. Engine overloaded.

I can not understand why front axle to make a lot of noise regularly at work?

This is gears damage. Replace gears. ball bearings crumbled. Replace it.

I'm the owner this model about 5 years. Often diesel engine start is intermittent. How to eliminate?

Nozzle has dirt. You should to diagnose a nozzle. The fuel pump has a malfunction. Repair fuel pump.

I have the same model. Explain to me what reason if differential lock assembly is defective immediately? How to solve the problem?

Diaphragm worn out or disks of the friction clutch are worn out. Replace parts.

Our company has MF 5475. Motor not starting. I need to know what's issue?

Possibly Dirt in the fuel system. Otherwise the fuel pump adjustment is not correct.

Please help me. Engine overheats regularly. What is the problem?

Low coolant level - Fill coolant and check cooling system for loose connections or leak. Radiator cap faulty - Replace with new one. Radiator core clogged - Clean radiator core. Radiator screen clogged - Clean screen. Motor overloaded - Reduce motor load. Broken or misadjusted fan belt - Adjust or replace.

My father has Massey Ferguson 5475. Yesterday he heard knocking in the rear axle. What is the malfunction?

All signs denote damaged bearings.

Please explain me what is defect if motor emits white smoke?

When white gas comes from the exhaust pipe you required to replace piston rings urgently. Insufficient fuel delivery. Shortage of or faulty fuel.