________________________________________________________________________________

MF 6180 tractor - Problem solving

The other day I discovered some problem on my Massey Ferguson 6180. Diesel engine will not crank over. Tell me please what kind of damage?

You must use the recommended fuel grade. Defective high pressure fuel pump. Check and overhaul. Wrong fuel injection pump timing. Adjustment required.

MF 6180 breakdowns. Low engine power. How can I troubleshoot it?

Seized fuel injectors and / or carbon deposit. The injectors are clogged, carbon coated and sticking.

Tell me what is fault if engine stops during operation?

Water mixed in the fuel - Remove water and replace with light oil.

6180 model failure. Transmission shifts hard. What happened?

Synchronizer worn, damaged, or improperly assembled - Replace or reassemble synchronizer.

Somebody help me why my steering wheel turns very easy? What are my actions to troubleshoot?

The minimum oil level - Pour completely. Steering cylinder has problems - Change the seal. Defect in the power steering pump - Check the steering pump.

I purchased a MF 6180 in september. Now there is failure. Diesel won't start. Can someone help me determine the cause of trouble?

Starter does not work - Check starter and replace if necessary. Fuel pipes are contaminated - Clean and wash. Fuel filter is dirty - Renstall filter element. Piston ring failure - Change piston rings.

I bought the same tractor. Recently I noticed steering wheel is hard to turn. Explain to me what is problem?

Minimum Oil Rating. Suction filter dirty. Clean and remove. Front wheels aligned wrong. Breakage of hydraulic hoses. Eliminate a fault. Steering pump is defective. Check the steering pump. Power steering has a defect. Replace it.

6180 tractor issue. Diesel hard to start. Help me please define the source of malfunction. What should I do?

Engine flooded. Engine oil filter restricted. Water, rust or stale fuel in tank. Incorrect functions of the cold start system. Broken or Worn Piston Rings. Injection pump drive shaft is defective. Water in fuel. Crankcase oil too heavy. Use oil of proper viscosity.

Massey Ferguson 6180 diesel failures. Diesel starts hard sometimes. How can i fix it?

Restricted Fuel Lines. Air in fuel tank. Bleed fuel tank. Exhaust pipe is clogged. Low voltage - Charge battery. Diesel injection nozzles faulty or sticking. Clogged fuel filter. Clean or replace fuel filter. Fuel shut-off valve closed. Open fuel shut-off valve.

Steering does not operate on our tractor. How can I fix it?

The air was formed in hydraulic system. You should release air from system. The minimum oil indicator in the tank. Fill the tank. Wear of the hydraulic steering cylinder Check and repair.

Having used the same tractor. Why diesel motor does not start? How do i fix this defect?

Valve timing is incorrect - Make adjustment. Bad compression. Cylinder bores are worn - Need overhaul. Leakage between seats and valves - Remove leakage.

6180 tractor issue. This is the engine knock. what is the trouble?

Oil of small quantity. You should pour this. Low engine speed. Oil level low.

I have a problem why front axle to rattle incessantly while driving?

Defective gear. You need to install new gears. ball bearings crumbled. Fit new bearings.

I have this tractor three years. Sometimes motor start is very difficult. What you need to fix?

Injector has dirt. You should to inspect injector. The fuel pump is not working. Install a new injection pump.

I bought the exact same tractor. Answer my question what's problem if locking differential broke down immediately? How to solve the problem?

The diaphragm torn or replace friction clutch discs. You have to make repairs.

I'm using MF 6180. Diesel engine does not start. I need to know how can I fix this?

Most likely this is a clogged fuel filter. Otherwise injection pump is improperly adjuste.

Need help. Diesel overheating occurs. What is the fault?

Lack of coolant in cooling system - Fill cooling system to proper level. Radiator core or side screens dirty - Clean radiator as required. Excessive load - Reduce load or speed. Loose or defective fan belt - Replace fan belt as required. Check belt tensioner.

My friend has Massey Ferguson 6180. Three days ago he heard a strange noise in the rear axle housing. What's wrong?

These sounds denote damaged bearings.

Please explain me what is fault if diesel engine white exhaust smoke?

If white gas comes from exhaust pipe you necessary to change piston rings immediately. Deficient compression - Adjust top clearance.