________________________________________________________________________________

New Holland 7610 - Troubleshooting

The other day I noticed trouble with my NH 7610. Diesel does not turn over. Explain me what is the probable issue?

You must use the recommended fuel grade. Defective high pressure fuel pump. Check and repair. Wrong fuel pump timing. Adjustment required.

New Holland 7610 failures. Reduced performance of the engine. How can I correct the situation?

Clean Air Screen. Clean Engine Cooling Fins. Engine air cleaner is clogged. Perform the service of the air cleaner.

Help anybody what is problem if diesel engine does not run smoothly?

Lack of fuel - Fill the tank and bleed the fuel system. Worn, stuck, or broken piston rings.

7610 model question. Transmission shift hard at low speeds. What's fault?

Transmission misaligned - Correct alignment.

Please give me information why my steering wheel turns too easy? What do I need to do to solve the problem?

Minimum Oil Rating - Top up the oil. Steering cylinder has damage - Change the seal. Pump steering broke - Install a new pump.

I acquired New Holland 7610 in march. Today there is breakdown. Diesel motor won't start. Can somebody help me define a source of problem?

Starter rotates slowly - Change or restore. Fuel pipes are contaminated - You need to perform cleaning and washing. The fuel filter element is dirty - Change it. Piston rings worn out - Install new piston rings.

I use the same tractor. Yesterday I saw steering wheel operate bad. Tell me what are possible malfunctions?

Low Oil Rating. The front wheels are not aligned correctly. Steering gear not properly adjusted (too tight). Hydraulic connections are not sealed. Eliminate the problem. Pump of power steering is broke. Replace the pump. Power steering is damaged. Replace it.

7610 tractor issue. Diesel engine starts hard. Please help me recognize the reason of malfunction. What do I need to check?

Broken choke or throttle cable. Choke adjusted incorrectly. Cold start system worked incorrectly. Defect or failure of piston rings. Defective fuel pump drive shaft. Water mixed in the fuel. Fuel too heavy at low temperature.

NH 7610 diesel failures. Engine long starting permanently. How do i solve a problem?

Restricted Fuel Lines. Air leakage to the fuel inlet. Exhaust pipe is clogged. Slow starter speed. Dirty or faulty injectors. Clogged fuel filter. Clean or replace fuel filter. Fuel shut-off valve closed. Open fuel shut-off valve.

Steering does not operate on our tractor. What's a breakdown?

Hydraulic system has a large amount of air. You need release air from system. Small level of hydraulic oil in system. Fill the tank. Steering cylinder has problems Change the seal.

I use the same model. Why motor failure to start? How can i resolve the question?

Wrong valve timing - Adjust valve timing. Low compression. Worn cylinder bores - Need overhaul. Leaks between valves and seats - Eliminate leakage.

New Holland 7610 issue. I hear a diesel knock. what kind of damage?

This is a small residue of engine oil. You should pour this. Coolant temperature dropped.

I can't figure it out why driving front axle to make a lot of noise chronically when driving?

Gears teeth crumbling. You need to install new gears. Bearings crumbled. Fit new bearings.

I'm the owner this model three years. Regularly diesel start is intermittent. What you need to fix?

Injector is clogged. You should to diagnose a nozzle. Injection pump has a malfunction. Repair high-pressure fuel pump.

I get the same tractor. Can someone explain to me why differential lock does not work suddenly? How to solve the problem?

Diaphragm worn out or wear of discs friction clutch. You have to make repairs.

Our company has NH 7610. Engine doesn’t want to work. Tell me what is problem?

We can assume Dirt in the fuel system. Otherwise high-pressure fuel pump is improperly adjuste.

Please help. Engine overheats regularly. What could be the problem?

Lack of coolant in cooling system - Fill cooling system to proper level. Dirty radiator core, or grille screens. Remove all trash. Excessive load - Reduce load or speed. Fan belt is damaged. Change as required.

My father has 7610 tractor. Today he got knocking in the rear axle housing. What is the malfunction?

These sounds talk about destruction of bearings.

Help with the question what is problem if motor excessive white smoke at idle?

When white smoke comes from exhaust pipe you must to replace piston rings immediately. Air filter blocked. Clean or replace as per maintenance schedule.