________________________________________________________________________________

New Holland TS100 - Repairs and maintenance

Lately I noticed a breakdown with my New Holland TS100. Motor does not turn over. Explain me what kind of problem?

Fuel grade is incorrect. Drive high pressure fuel pump is broken. Inspect and refit. Wrong fuel injection pump timing. Perform adjustment.

NH TS100 damages. Reduced performance of the engine. How can I fix an issue?

Remove and clean Air Filter. Remove and clean Muffler or replace. Restricted air filter. Insufficient fuel flow or quality.

Please explain me why irregular engine running?

Airlock in fuel line. Fuel-line is leaking air - Retighten clamps, replace defective pipes.

TS100 model problem. Transmission rough shifting. What happened?

Shift fork, shafts lever, or detents worn loose - Tighten or replace.

Please give me information why my steering wheel turns very easy? What are my actions for troubleshooting?

Low oil index - Pour full. This is a steering cylinder malfunction - Replace the defective part. The steering pump is defective - Replace pump.

I purchased New Holland TS100 in february. Today there is malfunction. Diesel engine won't start. Could somebody help me find a source of issue?

Starter faulty - Inspect the starter and install a new as required. Clogging in the fuel line - Wash and clean the fuel line. Filter element is dirty - Replace fuel filter. Worn piston rings - Refit a new set of piston rings.

I have the same tractor. Recently I noticed steering wheel works very badly. Explain to me what's malfunction?

Low hydraulic oil level in the tank. Poorly installed steering column - Correct. Faulty steering pump. Leak in hydraulic connections. It is necessary to fix a defect. Power steering pump defect. Install the new pump. Power steering defective. Install the new power steering.

TS100 tractor problem. Diesel motor starts hard. Need help to define prime cause of breakdown. What should I check?

Faulty fuel pump. Fuel filter is gummed or plugged. Stale or improper fuel. Tank vent restricted. Cold start system worked incorrectly. Piston rings are wear or deformed. Cracked injector Body or Cup. Water in fuel. Fuel too heavy at low temperature.

NH TS100 engine breakdowns. Diesel is difficult to start permanently. How can i fix it?

Restricted Fuel Lines. Air leakage to the fuel inlet. Exhaust pipe is clogged. Slow starter speed. Dirty or faulty injectors. Clogged fuel filter. Clean or replace fuel filter. Fuel shut-off valve closed. Open fuel shut-off valve.

Steering stopped working on my tractor. What is problem?

The air was formed in hydraulic system. You should remove air. The minimum hydraulic oil indicator in system. Top up the oil. Steering hydraulic cylinder worn out Repair it.

Having used the exact same tractor. Why diesel failure to start? How could i fix a failure?

Valve timing is improper - Make adjustment. Bad cylinder compression. Worn cylinder bores - Repair it. Leaks between seats and valves - Remove leakage.

TS100 tractor troubles. Diesel engine knocks. what could be the issue?

Oil of small quantity. Fill up. This is the low temperature of the coolant.

I can't figure it out why front axle to rattle incessantly at work?

Teeth of gears broke. It is recommended to replace the gear. Bearings have damage. Swap the replacement.

I own this model some years. Recently, engine start is difficult. What you need to fix?

Injection nozzle is dirty. You should checking injector. Injection pump does not work. Install a new high-pressure fuel pump.

I get the exact same tractor. Can anybody tell me what's problem if locking differential breaks down suddenly? What's solution to the problem?

This is the diaphragm rupture or disks of the friction clutch are worn out. Change worn components.

I'm using New Holland TS100. Diesel engine not starting. I need to know can i fix the problem?

Probably fuel filter clogged. Otherwise high-pressure fuel pump adjustment is not correct.

I have the problem. Engine overheats regularly. What is the fault?

Lack of coolant - Refill with coolant. Bearings are fitted too tight - Check and adjust. Loose or defective fan belt. Low coolant level. Lack of cooling water - Add cooling water. Excessive load - Reduce load or speed. Broken or misadjusted fan belt - Adjust or replace.

My friend has NH TS100. Three days ago he diagnosed a crash in the crankcase of the drive axle. What problem tell me?

All sounds talk about defect in the axle reducer.

Help with the question what is defect if diesel exhaust with white smoke?

If white smoke comes out of exhaust pipe you need to replace piston rings immediately. High engine oil level - Inspect oil level and correct.