________________________________________________________________________________
New Holland TS115 - Repairs and servicing
The other day I noticed a failure with my NH TS115. Diesel motor can not
crank over. Explain me what is the trouble?
Wrong type or grade of fuel used. Broken drive on fuel injection pump.
Inspect and replace. Incorrect fuel pump timing. Need to set up.
New Holland TS115 breakdowns. Engine loses power. How to troubleshoot
it?
Too much oil in engine. Uneven fuel injection - Replace injection pump.
Valve clearance incorrectly.
Tell me what is damage if diesel engine runs irregularly?
Engine overheating. Defective injection nozzle. Loose electrical
connections.
TS115 model question. Transmission rough shifting. What's the reason?
Differential bevel gears worn or damaged. Shifting gears while tractor
is in motion.
Here is my question - why steering wheel turns around without
opposition? What are my actions to fix an issue?
Low oil index - Pour full. This is a steering cylinder malfunction -
Perform repair. Steering pump have worn - Install a new pump.
I purchased NH TS115 in april. Nowadays there is malfunction. Engine not
starting. Can someone help me determine a source of failure?
Starter rotates slowly - Replace or repair. Fuel line is clogged up -
Clean and flush. Fuel filter is dirty - Change it. Piston ring failure -
Install new piston rings.
I use the same tractor. Recently, the steering is very hard. Explain to
me what are possible malfunctions?
Low Oil Rating. Airlock in steering system. Remove air from system. Tire
pressure uneven - Adjust it. Hydraulic connections are not sealed.
Eliminate a damage. Steering pump is worn out. Install the new pump.
Wear of power steering. Replace it.
TS115 model problem. Engine cranks but not starting. Need help to find
the cause of failure. What should I do?
High-speed and idle mixture needles not properly adjusted. Incorrect
functions of the cold start system. Wear or deformation of piston rings.
High pressure fuel pump drive shaft is broken. Water in fuel. Fuel too
heavy at low temperature.
New Holland TS115 engine problems. Diesel is difficult to start
sometimes. How can i resolve the question?
Restricted Fuel Lines. Air leakage to the fuel inlet. Exhaust pipe is
clogged. Slow starter speed. Dirty or faulty injectors. Clogged fuel
filter. Clean or replace fuel filter. Incorrect timing.
Steering not working on our tractor. Why did this happen?
The air is in hydraulic system. You need remove air. Minimum hydraulic
oil level in system. Top up the oil. Steering cylinder has problems
Repair it.
I am working on the same tractor. Why motor has not been started? How do
i solve a problem?
Wrong valve timing - Adjust valve timing. Bad compression. Cylinder
bores are worn - You must fix it. Leakage between seats and valves -
Remove leakage.
New Holland TS115 breakdowns. This is the engine knock. what is the
probable damage?
This is a small residue of engine oil. You should pour this. Engine oil
level low. Incorrect fuel - Fill with right fuel.
I can not understand why driving front axle is cracking regularly when
driving?
Teeth of gears collapsed. It is recommended to replace the gear.
Bearings are firmly erased. Replace it.
I have this model more than 3 years. Often engine start is difficult.
How to get rid of this?
Injector has clog. Need to diagnose a nozzle. The fuel pump has a
malfunction. Requires replacement of fuel pump.
I have the exact same model. Can anybody tell me what reason if locking
differential can break abruptly? How to solve the problem?
Diaphragm damaged or discs friction clutch worn out. You have to make
repairs.
We have TS115 tractor. Engine not working. Tell me what's issue?
We can assume fuel filter element has dirt. Otherwise injection pump is
improperly adjuste.
I have the problem. Motor constantly overheats. How to repair it?
Lack of coolant - Refill with coolant. Engine air intake screen plugged.
Engine gets overload - Decrease load or shift to low gear. Thermostat
faulty - Replace. Engine overloaded. Shift to lower gear or reduce load.
Loose or problem fan belt. Adjust belt tension.
My dad uses NH TS115. Yesterday he got a loud knocking in the rear axle
housing. What is the malfunction?
These sounds point to damaged bearings.
Please explain me what is defect if engine exhaust white gas?
When white gas comes out of exhaust pipe you necessary to replace piston
rings urgently. Injector pump or injectors delivering fuel unevenly.
Check and service injectors and injector pump – specialist operation.
________________________________________________________________________________
- ALL MODELS
- NH 2120 - Adjustment and overhaul
- NH 3010 - Adjustment and repair
- NH 6640 - Adjustments and maintenance
- NH 7630 - Adjustments and service
- NH 7740 - Adjustments and servicing
- NH 8970 - Maintenance and adjustments
- Boomer 3040 - Maintenance and repair
- Boomer 3045 - Maintenance and repairs
- Boomer 3050 - Maintenance issues
- NH G240 - Maintenance questions
- NH L85 - Maintenance work
- NH L95 - Malfunctions and repair
- NH M100 - Malfunctions and repairs
- NH M135 - Operating faults
- NH T3030 - Operating problems
________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________