________________________________________________________________________________

Ford 9600 Problems

The day before I got the problem with my Ford 9600. Diesel can not crank over. Explain me what could be the trouble?

You used an incorrect type of fuel. The fuel pump drive is faulty. Check and overhaul. Wrong fuel injection pump timing. Adjust if needed.

9600 tractor damages. Engine deficient output. How do I get rid of problem?

Incorrect fuel injection timing. Injection nozzle faulty or incorrect injection cycle. Insufficient fuel supply - Check fuel system.

Please explain me why engine runs irregularly?

Lack of fuel - Fill the tank and bleed the fuel system. Worn, stuck, or broken piston rings.

9600 tractor failure. Hard shifting transmission. What's the reason?

Improper shift linkage adjustment - Adjust linkage.

Please tell me why my steering wheel rotates very easy? What are my actions to solve the problem?

Low oil index - It is required to top up the oil. The steering cylinder is heavily worn - Change the seal. Pump steering broke - Install a new pump.

I purchased a Ford 9600 in february. Today there is trouble. Motor won't start. Can anyone help me diagnose the cause of failure?

Starter rotates slowly - Inspect the starter and install a new as required. Clogging in the fuel line - Flush and clean the fuel pipe. Filter element is dirty - Change the filter. Worn piston rings - Must be repaired.

I use the same tractor. Recently I noticed steering wheel turns heavy. Tell me what's malfunction?

Minimum Oil Rating. Faulty steering pump. Steering pump malfunction. Tight ball joints. hydraulic connection leaking. It is necessary to eliminate a defect. Pump of power steering is broke. Repair the pump. Wear of power steering. Replace it.

9600 tractor trouble. Diesel very hard starting. Please help me recognize prime cause of trouble. What should I check?

Fuel inlet needle sticking to seat. Fuel pump dirty or out of adjustment. Incorrect functions of the cold start system. Broken or Worn Piston Rings. Defective fuel pump drive shaft. Water mixed in the fuel. Crankcase oil too heavy. Use oil of proper viscosity.

Ford 9600 diesel engine issues. Engine starts hard sometimes. How do i fix malfunction?

Restriction in fuel tank vent. Air leak on the suction side of the system. Clogging in exhaust pipe. Slow starter speed. Dirty or faulty injectors. Filter clogged. Long Idle periods.

There was a malfunction of steering on my tractor. What's a breakdown?

The hydraulic system has air. You should release air from system. Small level of hydraulic oil in the tank. Top up the oil. Steering hydraulic cylinder worn out Repair it.

I am working on the same model. Why motor failure to start? How do i fix it?

Valve timing is wrong - Set a valve timing. Bad cylinder compression. Cylinder bores are worn - Need overhaul. Leaks between valves and seats - Eliminate leak.

Ford 9600 failures. Diesel knocks. what could be the failure?

This is a small residue of engine oil. Add oil. This is the low temperature of the coolant.

I can't figure it out why driving front axle is cracking chronically when tractor run?

Teeth of gears collapsed. You need to install new gears. ball bearings are firmly erased. You need to change it.

I'm the owner this tractor less than five years. Often diesel start is very difficult. How to get rid of this?

Nozzle has clog. You should checking injector. Injection pump has a breakdown. Replace fuel pump.

I get the exact same tractor. Can someone explain to me what reason if differential lock breaks down swiftly? How to solve the problem?

Diaphragm damaged or wear of discs friction clutch. You have to make repairs.

Our company has 9600 tractor. Diesel engine not working. I need to know what is the fault?

Possibly fuel filter element has dirt. Or the fuel pump not adjusted.

Need help. Diesel constantly overheats. What kind of malfunction?

Coolant level lowered. Pour liquid into radiator to recommended level. Choked radiator fins - Clean it. Insufficient coolant - Top up coolant. Choking of cooling system - Clean the cooling system. Engine overloaded - Reduce engine load. Fan belt is damaged. Change as required.

My father has Ford 9600. Three days ago he heard a crash in the crankcase of the drive axle. Which part is damaged?

All sounds denote defect in the axle reducer.

Can someone say me why motor emits white smoke?

If white smoke comes from the exhaust pipe you must to carry out replacement of piston rings immediately. Clogged air cleaner - Clean or replace elements.

FORD TRACTORS TROUBLESHOOTING
1710	1900	2120	2600	3600
3930	4100	4630	5600	5640
6410	6610	6640	6710	6810
7610	7740	7810	8210	8240
8630	8830	8770	TW30	TW35