________________________________________________________________________________
Cub Cadet LTX1046 Lawn Tractor Problems
Cub Cadet LTX 1046 Engine Troubleshooting
Kohler engine does not start
Fuel tank is empty - Add fuel.
Wrong grade of gasoline - Use correct fuel grade.
Stale gas - Drain gasoline and change with fresh.
Dirty fuel system - Check and clean.
Defective spark plug wires - Check wires connection.
Spark plug damaged - Test ignition spark.
Fuel filter is dirty - Fuel filter needs to be replaced.
Brake pedal not depressed - Press the brake pedal.
Carburetor problems - Carburetor diagnostics required.
Inspect and adjust choke. Check and adjust valve clearance.
Engine starts hard
Faulty spark plug - Test spark and replace as required.
Carburetor not adjusted - Adjust according to instructions.
Dirt in fuel lines - Clean the system carefully.
Choke cable damaged - Replacement required.
Old or incorrect fuel - Fill in proper fuel.
Electrical connection problems - Check and replace.
Starter problems - Check the starter and replace defective components.
Engine stalling, surging or running rough
Cooling fins blocked - Clean cooling fins.
Loose electrical connections - Check and repair defective connections.
Ignition setting defective - Check spark plug and ignition.
Throttle cable sticks - Check and repair.
Air cleaner blocked - Replace air cleaner.
Engine stops or misses
Faulty spark plug - Replace spark plug.
Carburetor problems - Test and repair.
Ignition coil air gap incorrect - Check and adjust ignition coil air
gap.
Kohler engine overheating
Engine overloaded - Reduce the load.
Air intake screen clogged - Clean dirty components.
Engine oil low or too high - Add or drain oil.
Improper engine oil viscosity - Change oil.
Check connecting rod to crankshaft bearing clearance.
Fast idle speed - Adjust carburetor idle mixture screw.
Engine does not idle
Poor spark plug contact - Adjust spark plug gap.
Spark plug fail - Test spark and replace as required.
Engine knocks
Low octane gasoline - Use proper fuel.
Engine overload - Reduce the load.
Lack of engine oil - Add to required level.
Low engine speed - Adjust the required speed.
Cylinder bore and rings are wear - Inspect cylinder bore or rings for
worn.
Inspect for engine overheats from clogged cooling fins.
Check and adjust valve clearance.
Check for loose or worn connecting rods.
Kohler engine backfires
Check spark plug for fouled.
Adjust or change the choke.
Adjust carburetor idle mixture screw.
Check and adjust ignition coil air gap.
Inspect for sticking valves.
Checking and adjusting valve clearance.
Inspecting flywheel key.
Engine does not develop full power
Engine overheats - Clogged air filter element.
Engine oil overfilled - Remove excess oil.
Faulty fuel pump - Inspect and repair fuel pump.
Defective governor - Repair or replace governor.
Check carburetor float adjustment.
Check engine compression.
Excessive Fuel Consumption
Throttle did not open fully - Replace choke cable.
Carburetor malfunction - Check carburetor float adjustment.
Black exhaust smoke
Air filter element plugged - Clean or change filter.
Choke partially engaged - Inspect and adjust throttle.
Checking and adjusting carburetor float level.
Cub Cadet LTX1046 Electrical System
Troubleshooting
Starter motor will not turn engine
Blown main fuse - Installing new fuse.
Battery terminals are corroded - Clean connections.
Low-voltage battery - Charge the battery.
Ignition switch defective - Replace switch.
Starter fault - Repair or replace.
Wiring damage - Replace wiring.
Battery does not charge
One or more battery cells dead - Change the battery.
Battery cables and terminals are dirty - Replace or clean cable.
No Lights work
Light plug not connected - Reconnect
Replace light bulbs.
Wiring damaged - Check and replace.
Cub Cadet LTX 1046 Machine Troubleshooting
Tractor vibrates too much or rattles
excessively
Implements drive belts damaged or worn - Check and replace worn belt.
Worn traction drive belt - Check and replace belt.
Dirt on driven pulley - Installing a new pulley.
Mower blades malfunction - Tighten and balance blade.
Tractor will not move with engine running
Parking brake is applied - Release the park brake.
Bypass valve lever activated - Disengage the bypass valve lever.
Loose lawnmower blades - Fasten the blades securely.
Incorrect blade balancing - Check mower blade balancing.
Transmission oil is low - Fill transmission with oil.
Cub Cadet LTX 1046 Lawn Mower Problems
Discharge Chute Plugged
Speed too high - Use slower speed.
Too high grass for mowing - Adjust the mower to a lower cutting height.
The grass is wet - Wait for the grass to dry.
Engine runs at low revs - Increase engine rpm.
Restricted air flow - Adjust to high revs.
Mower deck set to low cutting - Change cutting height.
Belt installed incorrectly - Fit belt correctly.
Lawn mower leaving uncut grass
Mower's cutting deck is clogged - Check cutting deck and clean if
necessary.
Excessive blade wear - Installing new blade.
Deck too low - Deck leveling required.
Grass bagger overfilled - Empty the grass bag.
Speed is very high - Use slower speed.
Slipping drive belt
Sheave is dirty - Pulley cleaning required.
Worn belt - Check and change damaged belt.
Belt tension is incorrect - Adjust belt tension.
Excessive mower vibration
Debris in mower deck or in pulleys - Clean sheave and deck from
clogging.
Belt or pulley faulty - Fit new components.
Misaligned belt or pulley - Check and adjust.
Blades out of balance - Blades need balancing.
Blades scalp grass
Wrong cutting height - Check and adjust height.
Mower height wheels not adjusted - Adjust mower deck wheels.
Insufficient tire pressure - Tire pressure required.
Blades speed too fast - Blade speed required.
Bent blades during operation - Install new blades.
Uneven Cut
Deck too low - Deck leveling required.
Tire pressure unequal - Inflate tires as required.
Wrong wheel position - Adjust rear or front wheel height.
Travel speed too high - Use slower speed.
Blades dull - Install new blade.
- Cub Cadet 682 Engine
- Cub Cadet 782 Engine
- Cub Cadet GT1554 Engine
- Cub Cadet LT1042 Engine
- Cub Cadet LT1046 Engine
- Cub Cadet LT1050 Engine
- Cub Cadet LTX 1040 Engine
- Cub Cadet LTX 1042 Engine
- Cub Cadet LTX 1045 Engine
- Cub Cadet XT1 LT46 Engine
________________________________________________________________________________
________________________________________________________________________________________
CUB CADET TRACTORS SPECIFICATIONS |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
ENGINES FOR CUB CADET LAWN TRACTORS |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
CUB CADET TRACTORS TROUBLESHOOTING | ||||
1050 | 1863 | 2166 | 2182 | 2186 |
3184 | 3205 | GT1554 | GT2550 | GTX2100 |
LT1040 | LT1042 | LT1045 | LT1046 | LT1050 |
LT2180 | LTX1040 | LTX1042 | LTX1045 | LTX1046 |
LTX1050 | SLTX1054 | XT1 LT42 | XT1 LT46 | XT3 GSX |