________________________________________________________________________________

Kubota L35 - Problem Solving

The day before I noticed a failure with my Kubota L35 TLB. Diesel doesn't turn over. Tell me what is the probable breakdown?

You used an incorrect type of fuel. Defective high pressure fuel pump. Check and repair. Incorrect fuel pump timing. Adjust if necessary.

L35 tractor damages. Insufficient engine power. How do I solve the problem?

Worn piston rings and valve guides. Replace them with new ones. Wrong fuel injection advance angle. Set the recommended injection advance angle.

Help with the question what is damage if engine runs unevenly?

Airlock in fuel line. Fuel-line is leaking air - Retighten clamps, replace defective pipes.

L35 tractor question. Transmission shifts hard. What's fault?

Differential bevel gears worn or damaged. Shifting gears while tractor is in motion.

Please tell me why steering wheel rotates not resisting? How do I act for troubleshooting?

Low oil index - It is required to add oil. The steering cylinder is heavily worn - Repair it. Steering pump have worn - Repair pump.

I got a Kubota L35 backhoe in july. Currently there is malfunction. Engine will not start. Could someone help me define a source of trouble?

Starter motor turns engine too slowly - Need a replacement or overhaul. Fuel line is clogged up - You need to perform cleaning and washing. Filter element is dirty - Install new filter. Wear piston rings - Install new piston rings.

I have the same tractor. Recently, the steering stopped working. Explain to me what is problem?

Low oil index. Power steering oil too thick – high viscosity. Replace with the specified oil. Oil flows out of the system. Eliminate a damage. Pump of power steering is broke. Repair the pump. Power steering defect. Install the new power steering.

L35 tractor trouble. Diesel engine starts hard. Please help me recognize occasion of failure. What needs to be repaired?

Improper engine oil viscosity. Loose electrical connections. Incorrect functions of the cold start system. Wear or deformation of piston rings. Defective fuel pump drive shaft. Water in fuel. Fuel too heavy at low temperature.

Kubota L35 diesel engine damages. Engine hard starting permanently. How could i resolve an issue?

Restricted Fuel Lines. Air leaks on suction lines. Clogging in exhaust pipe. Low voltage - Charge battery. Injection fuel is little or the spray is not excellent. Clogged fuel filter. Clean or replace fuel filter. Incorrect timing.

Steering not working on our tractor. What is problem?

Hydraulic system has a large amount of air. We recommend you release air from system. The minimum hydraulic oil indicator in the tank. Fill the tank. Steering hydraulic cylinder worn out Check and repair.

I am working on the same model. Why engine does not start? How can i solve a problem?

Valve timing is incorrect - Adjust valve timing. Low compression. Cylinder bores wear - You must fix it. Leaks between valves and seats - Need Removal of leakage.

L35 TLB failures. This is the engine knock. what kind of damage?

Oil of small quantity. You should pour this. Too much bearing play. Injection volume incorrectly set - Adjust settings.

I can't figure it out why front axle is cracking constantly when driving?

Gears teeth crumbling. You must change the gears. Bearings are firmly erased. Replace it.

I own this tractor less than five years. Regularly motor start is very difficult. What you need to fix?

Injector is dirty. You must to inspect a nozzle. High-pressure fuel pump does not work. Replace fuel pump.

I have the same model. Can someone explain to me what's problem if differential lock assembly can break immediately? How to solve the problem?

Diaphragm damaged or disks of the friction clutch are worn out. You have to make repairs.

I have Kubota L35 backhoe. Diesel engine not working. Tell me what is problem?

Possibly this is a clogged fuel filter. Otherwise high-pressure fuel pump adjustment is not correct.

Need help. Diesel overheats regularly. How to repair it?

Lack of coolant - Refill with coolant. Fan belt slipping - Adjust belt tension. Flywheel fins broken or damaged. Too much scale in the water jacket. De-scale the water jacket. Motor overloaded - Reduce motor load. Fan belt is damaged. Change as required.

My dad uses Kubota L35 TLB. Three days ago he heard a crash in the crankcase of the drive axle. Which part is damaged?

All sounds evidence of defect in the axle reducer.

Help with the question what damage if diesel exhaust with white smoke?

If white smoke appeared from the exhaust pipe you required to change piston rings immediately. Injector pump or injectors delivering fuel unevenly. Check and service injectors and injector pump – specialist operation.