________________________________________________________________________________

Kubota L3600 Troubleshooting

Some days ago I discovered a malfunction on my L3600 tractor. Diesel does not crank. Tell me please what is the failure?

Fuel grade is incorrect. High-pressure fuel pump is damaged. Check and overhaul. Incorrect fuel pump timing. Adjust if necessary.

Kubota L3600 damages. Poor engine performance. How to get rid of problem?

Fuel filter, fuel prefilter, water separator or fuel line clogged - Replace fuel filter unit. Clean fuel prefilter, water separator, fuel line.

Help anybody why diesel engine stalling?

Airlock in fuel line. Fuel-line is leaking air - Retighten clamps, replace defective pipes.

L3600 tractor trouble. Transmission rough shifting. What's fault?

Shift fork, shafts lever, or detents worn loose - Tighten or replace.

Somebody help me why my steering wheel rotates very easy? What are my actions for troubleshooting?

Low Oil Rating - Top up the oil. The steering cylinder is heavily worn - Replace the defective part. Defect in the power steering pump - Replace pump.

I got a Kubota L3600 in february. Currently there is problem. Diesel engine won't start. Can someone help me determine the source of damage?

Starter speed is slow - Replace or repair. Fuel pipes are contaminated - Flush and clean the fuel pipe. Fuel filter is dirty - Change it. Piston rings worn out - You need repair.

I bought the same tractor. Recently, steering wheel works very badly. Tell me what is problem?

Minimum Oil Rating. Pour completely. Oil flows out of the system. Eliminate a damage. Steering pump is worn out. Replace the pump. Power steering defect. Install the new power steering.

L3600 tractor failure. Diesel starts hard. Need help to define prime cause of problem. What needs to be repaired?

Fuel pump is not adjusted properly or dirty. Fuel shut-off valve closed. Cold start system worked incorrectly. Broken or Worn Piston Rings. Broken Fuel Pump Drive Shaft. Water mixed in the fuel. Crankcase oil too heavy. Use oil of proper viscosity.

Kubota L3600 diesel engine problems. Motor long starting regularly. How can i fix a failure?

Restricted Fuel Lines. Air Leaks in Suction Lines. Restriction in exhaust pipe. Slow starter speed. Diesel injection nozzles faulty or sticking. Filter clogged. Incorrect timing.

Steering not working on my tractor. How can I fix it?

The air is in hydraulic system. You must draw out air. Oil low level in system. Pour completely. Problem with the hydraulic steering cylinder Repair it.

I am working on the exact same tractor. Why diesel does not start? How can i fix this defect?

Valve timing is wrong - Set a valve timing. Bad cylinder compression. Cylinder bores wear - You must fix it. Leaks between valves and seats - Remove leaks.

Kubota L3600 troubles. I hear the engine knocking. what could be the damage?

Lack of oil. You should pour this. Coolant temperature dropped.

I can not understand why tractor front axle is cracking chronically while driving?

Teeth of gears broke. You must change the gears. ball bearings crumbled. You need to change it.

I own this tractor about 4 years. Often diesel start is very hard. What you need to fix?

Nozzle has clog. Need to inspect injector. The fuel pump problems. Replace high-pressure fuel pump.

I have the same tractor. Explain to me what's problem if locking differential can break abruptly? How to solve the problem?

Diaphragm damaged or disks of the friction clutch are worn out. Requires repair.

We have L3600 tractor. Engine will not start. I need to know what is problem?

Probably Dirt in the fuel system. Or the fuel pump is improperly adjuste.

I have trouble. Diesel overheating occurs. What kind of malfunction?

Lack of coolant - Refill with coolant. Temperature thermostat is out of order, or insufficient coolant in tank. Check and replace the thermostat or replenish coolant. Engine overloaded. Shift to lower gear or reduce load. Fan belt is damaged. Change as required.

My friend has Kubota L3600. Three days ago he diagnosed a crunch in the rear axle housing. What's wrong?

These symptoms evidence of defect in the axle reducer.

Please explain me what is fault if diesel excessive white smoke at idle?

If white smoke appeared from the exhaust pipe you need to change piston rings immediately. High engine oil level - Inspect oil level and correct.