________________________________________________________________________________

Kubota L3650 Problems

The other day I found out some issue with my Kubota L3650. Engine can not turn over. Tell me what is the failure?

Fuel grade is wrong. Defective high pressure fuel pump. Inspect and refit. Timing of fuel injection pump is incorrect. Adjust if needed.

L3650 tractor issues. Low engine power. How should I troubleshoot it?

Seized fuel injectors and / or carbon deposit. The injectors are clogged, carbon coated and sticking.

Tell me please why diesel engine runs but misses?

Bearing bush burning-out. Check and replace it. Fuel line or fuel filter plugged.

Kubota L3650 tractor failure. Transmission shifts hard. What happened?

Worn or defective clutch - Replace worn parts.

Somebody help me why my steering wheel spinning too easy? What are my actions for troubleshooting?

Minimum Oil Rating - It is required to add oil. Steering cylinder has damage - Change the seal. Steering pump have worn - Repair pump.

I bought a L3650 tractor in september. Presently there is failure. Diesel won't start. Could someone help me determine a source of damage?

Starter motor turns engine too slowly - Change or restore. Dirt in the fuel system - Clean and wash. The fuel filter element is dirty - Renstall filter element. Piston rings are not free or they are worn or broken - Install new piston rings.

I have the same tractor. Recently I noticed steering wheel operate very badly. Tell me what is problem?

Low hydraulic oil level in the tank. Incorrect toe-in. Improper alignment of front wheels - Replace tie-rod. Oil flows out of the system. It is necessary to eliminate the problem. Power steering pump defect. Replace the pump. Power steering has a defect. Diagnose the power steering.

L3650 tractor failure. Diesel very hard starting. Please help me identify main cause of issue. What needs to be repaired?

Restriction in air filter/cleaner or induction system. Cold start system used incorrectly. Piston rings are wear or deformed. Valve Leakage/Adjustment Bad. Water in fuel. Crankcase oil too heavy. Use oil of proper viscosity.

Kubota L3650 engine failures. Diesel hard starting permanently. How do i fix this defect?

Clogging in fuel tank vent. Air leaks on intake hoses. Restriction in exhaust pipe. Low voltage - Charge battery. Dirty or faulty injectors. Filter clogged. Incorrect timing.

Steering stopped working on our tractor. What is problem?

Hydraulic system has a large amount of air. We recommend you release air from system. Minimum hydraulic oil level in system. It is required to add oil. Steering cylinder has problems Replace the faulty part.

I am working on the exact same tractor. Why engine doesn't start? How could i solve a problem?

Improper valve timing - Set a valve timing. Compression increase. Cylinder bores wear - Need overhaul. Leaks between seats and valves - Eliminate leakage.

Kubota L3650 issues. I hear a diesel knock. what is the probable trouble?

Oil of small quantity. Add oil. Engine oil level low. Incorrect fuel - Fill with right fuel.

I can't find the reason why driving front axle to howls chronically at the moment of motion?

Defective gear. Replace gears. Roller bearings crumbled. Fit new bearings.

I'm the owner this model about 5 years. Often engine start is very difficult. How to get rid of this?

Injector is dirty. Need to inspect injector. The fuel pump problems. Repair high-pressure fuel pump.

I bought the same tractor. Answer my question why differential lock assembly breaks down abruptly? How to solve the problem?

Diaphragm worn out or discs friction clutch worn out. Requires repair.

I'm using Kubota L3650. Engine not working. Help me what is the fault?

Most likely fuel filter element has dirt. Otherwise injection pump adjustment is not correct.

Please help. Engine overheating occurs. What is the problem?

Low coolant level. Fill radiator to proper level, check radiator, coolant recovery tank, and hoses for loose connection or leaks. Radiator screen or fins clogged - Clean radiator screen or fins. Motor overloaded - Reduce motor load. Loose or problem fan belt. Adjust belt tension.

My father has L3650 tractor. Today he heard a crash in the rear axle. What's wrong?

These signs evidence of damaged bearings.

Help with the question what is defect if engine white exhaust smoke?

When white smoke appeared from the exhaust pipe you required to change piston rings immediately. Worn cylinder liner and piston rings. Replace them with new ones.