________________________________________________________________________________

Kubota M5700 Troubleshooting

Two days ago I recognized a malfunction on my M5700 tractor. Diesel engine doesn't crank. Tell me please what could be the damage?

You must use the recommended fuel grade. The fuel pump drive is faulty. Diagnose and change. Incorrect fuel injection pump timing. Need to set up.

Kubota M5700 breakdowns. Engine loses power. How should I solve the problem?

Engine shrouding plugged (overheats). High-speed and tdle mixture needle not properly adjusted. Incorrect injector timing. Adjust.

Help anybody why engine stalls?

Air in the fuel lines or filter element blocked. Check, bleed air or replace the filter element.

M5700 tractor issue. Transmission shift hard at low speeds. What's the reason?

Shift quadrant not properly adjusted. Worn shifter lever assembly.

Here is my question - why my steering wheel rotates too easy? What should I do for troubleshooting?

Low Oil Rating - Top up the oil. Steering cylinder has a defect - Change the seal. The steering pump is defective - Install a new pump.

I got a Kubota M5700 in november. Presently there is issue. Motor not starting. Can someone help me find a source of failure?

Starter turns bad - Change or refit. Fuel pipes are contaminated - Clean and wash. Filter element is dirty - Replace fuel filter. Piston ring failure - You need repair.

I have the same model. Recently, the steering is very hard. Tell me what is a breakdown?

Low hydraulic oil level in the tank. Power steering oil too thick – high viscosity. Replace with the specified oil. Hydraulic connections are not sealed. It is necessary to eliminate a damage. Pump of power steering is broke. Install the new pump. Power steering defective. Diagnose the power steering.

M5700 tractor issue. Diesel engine very hard starting. Need help to diagnose the reason of failure. What should I check?

Clogging in air filter/cleaner. Incorrect functions of the cold start system. Piston rings are worn or broken. Cracked injector Body or Cup. Water, dirt, or air in fuel system. Drain, flush, fill and bleed system. Fuel too heavy at low temperature.

Kubota M5700 motor problems. Diesel engine starts hard regularly. How do i fix it?

Clogging in fuel tank vent. Air leakage to the fuel inlet. Restriction in exhaust pipe. Low voltage - Charge battery. Diesel injection nozzles faulty or sticking. Filter clogged. Fuel shut-off valve closed. Open fuel shut-off valve.

Steering stopped working on my tractor. What's a breakdown?

The hydraulic system has air. You must release air from system. The minimum oil level in the tank. Top up the oil. Steering hydraulic cylinder is damaged Repair it.

I am working on the same tractor. Why diesel failure to start? How do i fix damage?

Improper valve timing - Adjust valve timing. Low compression. Cylinder bores wear - You must fix it. Leakage between seats and valves - Remove leaks.

Kubota M5700 damages. This is a diesel knock. what is the probable damage?

Oil of small quantity. Fill up. Too much bearing play. Injection volume incorrectly set - Adjust settings.

I have a problem why front axle is cracking regularly during operation?

This is the failure of any gear. You need to install new gears. ball bearings have damage. You need to change it.

I own this tractor about 5 years. Sometimes motor start is difficult. What a breakdown?

Injector has clog. You must checking injector. The fuel pump does not work. Install a new injection pump.

I have the same tractor. Can someone explain to me what's problem if locking differential does not work immediately? How can I fix it? What should I do?

Diaphragm damaged or replace friction clutch discs. You have to make repairs.

Our company has M5700 tractor. Engine not working. I need to know what is problem?

Most likely this is a clogged fuel filter. Otherwise injection pump is improperly adjuste.

Please help me. Motor overheating occurs. How to repair it?

Lack of coolant - Refill with coolant. Clean the radiator from dirt and dust, if necessary, clean cooling system from scale. Adjust the fan belt tension. Detect the faulty injectors, wash, clean and adjust them. Engine overloaded - Reduce engine load. Loose or fan belt issue - Adjust fan belt and replace if needed.

My father has Kubota M5700. Day before yesterday he got a crunch in the rear axle. What's wrong?

These signs talk about defect in the axle reducer.

Help with the question what happened if diesel excessive white smoke at idle?

If white gas comes from exhaust pipe you need to replace piston rings immediately. Excessive engine oil - Reduce to specified level.