________________________________________________________________________________

Kubota M6060 - Problems and Solutions

Recently I discovered a failure with my Kubota M6060 cab. Motor can not rotate. Tell me please what kind of malfunction?

You used an incorrect type of fuel. The injection pump is broken. Inspect and replace. Incorrect fuel pump timing. Need to set up.

M6060 tractor issues. Insufficient engine power. How can I troubleshoot it?

Low compression - Have it repaired by the service representative. Poor atomization at nozzle. Service or replace it.

Tell me what is fault if diesel engine runs but misses?

Air in the fuel lines or filter element blocked. Check, bleed air or replace the filter element.

M6060 question. Transmission shifts hard in reverse. What's the reason?

Defective or worn clutch - Change worn parts.

I would like to know why steering wheel rotates without resistance? What should I do to fix an issue?

Low oil index - Fill the tank. Possible malfunction steering hydraulic cylinder - Change the seal. The steering pump is defective - Replace pump.

I got a Kubota M6060 cab in september. Presently there is issue. Diesel won't start. Can anyone help me diagnose the source of issue?

Starter motor turns engine too slowly - Inspect the starter and install a new as required. Clogging in the fuel line - Clean and wash. Filter element is dirty - Replace fuel filter. Piston rings are damaged - Must be repaired.

I have the same tractor. Yesterday I saw steering wheel turns hard. Tell me what are possible malfunctions?

Low Oil Rating. Incorrect toe-in. Improper alignment of front wheels - Replace tie-rod. Breakage of hydraulic hoses. It is necessary to eliminate a damage. Power steering pump defect. Replace the pump. Hydraulic power steering is defective. Replace it.

M6060 tractor failure. Diesel engine is hard to start. Help me please diagnose the cause of failure. What do I need to check?

Loose or damaged wiring. Check all wiring. Weak or dead battery. Cold start system worked incorrectly. Piston rings are wear or deformed. Gasket Blow-By or Leakage. Water mixed in the fuel. Fuel too heavy at low temperature.

Kubota M6060 diesel damages. Engine hard starting permanently. How can i resolve an issue?

Clogging in fuel tank vent. Air leaks on suction lines. Exhaust pipe is clogged. Slow starter speed. Dirty or faulty injectors. Filter clogged. Long Idle periods.

There was a breakdown of the steering on my tractor. Why did this happen?

The air was formed in hydraulic system. We recommend you remove air. Oil small indicator in the tank. Fill the tank. Steering hydraulic cylinder worn out Replace the faulty part.

I have the same model. Why engine has not been started? How could i fix malfunction?

Valve timing is wrong - Set a valve timing. Compression increase. Cylinder bores wear - Repair it. Leakage between valves and seats - Need Removal of leakage.

Kubota M6060 breakdowns. Diesel knocks. what is the probable trouble?

Oil of small quantity. You should pour this. Cooling temperature is minimum.

I can't figure it out why tractor front axle produces a rumble chronically while driving?

This is gears damage. It is recommended to replace the gear. Roller bearings are firmly erased. Fit new bearings.

I own this tractor about 4 years. Often motor start is difficult. How to eliminate?

Injector has clog. You must checking injector. The fuel pump problems. Repair high-pressure fuel pump.

I get the exact same tractor. Tell me what reason if locking differential is damaged immediately? How to solve the problem?

Diaphragm damaged or replace friction clutch discs. Replace parts.

I'm using Kubota M6060 cab. Diesel engine does not start. Tell me what is problem?

Most likely fuel filter element has dirt. Or injection pump not adjusted.

I have trouble. Diesel overheats regularly. What kind of malfunction?

Little coolant in the cooling system. You need to fill the system. Connecting rod or crankshaft bearings worn. Coolant flow route corroded. Engine overloaded. Adjust the gearing. Excessive engine load. Too much load - you must reduce the load or speed. Loose or problem fan belt. Adjust belt tension.

My friend has M6060 tractor. Day before yesterday he diagnosed a noise in the rear axle housing. What's wrong?

All signs evidence of destruction of bearings.

Can someone say me why engine excessive white smoke at idle?

If white gas appeared from the exhaust pipe you need to change piston rings urgently. Piston ring and cylinder worn or stuck - Repair or replace.