________________________________________________________________________________

Massey Ferguson 5608 Troubleshooting Issues

Recently I recognized trouble on my Massey Ferguson 5608. Diesel doesn't crank over. Tell me what could be the trouble?

You used an incorrect type of fuel. Malfunction of the fuel pump. Diagnose and change. Wrong fuel pump timing. Need to set up.

MF 5608 breakdowns. Poor engine output. How should I correct the situation?

Compression leak - Replace head gasket, tighten cylinder head screw, glow plug and nozzle holder. Engine not broken-in.

Tell me please what is problem if irregular diesel engine running?

Engine seizure due to low or poor oil. Fuel supply pump faulty. Stale or dirty fuel.

5608 model failure. Transmission shift hard at low speeds. What's fault?

Front bearing retainer loose or cracked - Tighten or replace retainer.

Here is my question - why my steering wheel spinning without opposition? What should I do to correct the situation?

The minimum oil level - Fill the tank. Steering cylinder has damage - Replace the defective part. Defect in the power steering pump - Replace pump.

I acquired a Massey Ferguson 5608 in november. Currently there is breakdown. Diesel not starting. Can anybody help me identify the cause of failure?

Starter does not work - Need a replacement or overhaul. Clogging in the fuel line - Flush and clean the fuel pipe. There is dirt in the fuel filter - Install new filter. Piston rings are damaged - Change piston rings.

I use the same tractor. Recently I noticed steering wheel works heavy. Explain to me what's issue?

Low hydraulic oil level in tank. Power steering oil too thick – high viscosity. Replace with the specified oil. Hydraulic connections are not sealed. It is necessary to eliminate the problem. Steering pump is defective. Check the steering pump. Wear of power steering. Replace it.

5608 model question. Engine very hard starting. Please help me determine occasion of trouble. What needs to be repaired?

Loose or damaged wiring. Check all wiring. Weak or dead battery. Incorrect functions of the cold start system. Defect or failure of piston rings. High pressure fuel pump drive shaft is broken. Water in fuel. Fuel too heavy at low temperature.

MF 5608 diesel failures. Diesel starts hard regularly. How could i fix it?

Clogging in fuel tank vent. Air in fuel tank. Bleed fuel tank. Clogging in exhaust pipe. Slow starter speed. Diesel injection nozzles faulty or sticking. Filter clogged. Long Idle periods.

Steering does not operate on my tractor. Why did this happen?

The air was formed in hydraulic system. You must draw out air. The minimum oil level in system. It is required to add oil. Possible malfunction of hydraulic steering cylinder Repair it.

I own the exact same tractor. Why diesel engine does not start? How do i resolve an issue?

Valve timing is improper - Make adjustment. Compression increase. Wear cylinder bores - Need overhaul. Leakage between valves and seats - Eliminate leak.

5608 tractor issues. This is a diesel motor knock. what could be the malfunction?

Oil of small quantity. Fill up. Engine out of time. Excessive engine load.

I can not understand why driving front axle to rattle continuously at the moment of motion?

This is gears damage. You must change the gears. Bearings have damage. Swap the replacement.

I have this tractor three years. Recently, diesel starting is intermittent. What you need to fix?

Nozzle is dirty. It is required to inspect a nozzle. High-pressure fuel pump is not working. Do overhaul of high-pressure fuel pump.

I get the same tractor. Answer my question what's problem if locking differential can break abruptly? How to solve the problem?

The diaphragm torn or disks of the friction clutch are worn out. Requires repair.

Our company has Massey Ferguson 5608. Engine does not start. I need to know what's issue?

Probably Dirt in the fuel system. Otherwise the fuel pump not adjusted.

Please help. Diesel overheating occurs. What kind of malfunction?

Little coolant in the cooling system. You need to fill the system. Engine oil low or too high. Engine operated too long at slow engine speed. Thermostat sticking or inoperative. Too much oil in crankcase. Motor overloaded - Reduce motor load. Loose or fan belt issue - Adjust fan belt and replace if needed.

My brother has a MF 5608. Day before yesterday he heard a crash in the rear axle. What is the malfunction?

These symptoms talk about defect in the axle reducer.

Can someone say me why diesel exhaust white gas?

If white gas comes from the exhaust pipe you required to replace piston rings immediately. Worn cylinder liner and piston rings. Replace them with new ones.