________________________________________________________________________________

MF 7616 Trouble - Repair methods

The day before I recognized the damage on my 7616 tractor. Diesel doesn't crank over. Tell me please what is the failure?

You must use the recommended fuel grade. High-pressure fuel pump is damaged. Inspect and refit. Incorrect fuel pump timing. Adjustment required.

Massey Ferguson 7616 damages. Low engine power. How should I correct the situation?

Incorrect valve timing. Check and adjust, or replace cam shaft if necessary. Travel speed is too fast for conditions.

Can someone say me what is fault if engine stops suddenly?

Seized engine due to lack of oil, the wrong oil or lack of coolant.

7616 tractor failure. Hard shifting transmission. What's the reason?

Worn or defective clutch - Replace worn parts.

Please give me information why my steering wheel spinning not resisting? What should I do to correct the situation?

Low hydraulic oil level in tank - Top up the oil. Steering cylinder has damage - Change the seal. Steering pump have worn - Replace pump.

I got MF 7616 in february. Nowadays there is failure. Diesel won't start. Could anybody help me identify the source of issue?

Starter faulty - Change or restore. Fuel line is clogged up - You need to perform cleaning and washing. Fuel filter is dirty - Change the filter. Piston rings are not free or they are worn or broken - You need repair.

I use the same model. Recently I noticed steering wheel is hard to turn. Help me find out what's issue?

Low oil index. Poorly installed steering column - Correct. Faulty steering pump. Hydraulic connections are not sealed. It is necessary to eliminate a defect. Power steering pump defect. Repair the pump. Hydraulic power steering is defective. Replace it.

7616 model question. Diesel engine hard starting. Need help to recognize prime cause of breakdown. What do I need to check?

Stale or dirty fuel. Empty fuel tank and refill tank with fresh, clean diesel fuel. Incorrect functions of the cold start system. Broken or Worn Piston Rings. Gasket Blow-By or Leakage. Water in fuel. Crankcase oil too heavy. Use oil of proper viscosity.

Massey Ferguson 7616 diesel motor troubles. Diesel is difficult to start sometimes. How could i resolve the question?

Restricted Fuel Lines. Air Leaks in Suction Lines. Exhaust pipe is clogged. Low voltage - Charge battery. Dirty or faulty injectors. Filter clogged. Fuel shut-off valve closed. Open fuel shut-off valve.

Steering does not operate on our tractor. Why did this happen?

The hydraulic system has air. You must remove air. The minimum oil level in system. It is required to add oil. Steering cylinder has problems Repair it.

I own the exact same tractor. Why diesel doesn't start? How can i fix malfunction?

Valve timing is incorrect - Make adjustment. Bad cylinder compression. Cylinder bores wear - Repair it. Leaks between seats and valves - Need Removal of leakage.

MF 7616 failures. Diesel knocks. what is the probable trouble?

Lack of oil. Add oil. Too much bearing play. Injection volume incorrectly set - Adjust settings.

I can't find the reason why front axle to rattle chronically at work?

This is the failure of any gear. You need to install new gears. Roller bearings are very worn out. Fit new bearings.

I own this model some years. Often motor start is very hard. What a breakdown?

Injector is dirty. It is required to diagnose injector. The fuel pump problems. Repair fuel pump.

I get the exact same tractor. Answer my question why differential lock breaks down swiftly? How to solve the problem?

Diaphragm damaged or wear of discs friction clutch. Change worn components.

We have Massey Ferguson 7616. Engine does not start. I need to know what's issue?

We can assume fuel filter clogged. Or the fuel pump to lost adjustments.

Need help. Diesel overheats regularly. What could be the problem?

Lack of coolant - Refill with coolant. Clogged radiator fins - Clean the radiator fins. Internal wear limits out of specification. Injector timing is too advanced. Adjust as per specification. Engine overloaded - Reduce engine load. Loose or fan belt issue - Adjust fan belt and replace if needed.

My father has MF 7616. Yesterday he diagnosed knocking in the rear axle. What's wrong?

These symptoms denote destruction of bearings.

Tell me what is defect if motor exhaust white gas?

When white smoke comes from the exhaust pipe you required to replace piston rings immediately. Piston ring and cylinder worn or stuck - Repair or replace.