________________________________________________________________________________

MF 7624 Problem - User questions

A week ago I recognized some issue with my Massey Ferguson 7624. Motor doesn't crank. Tell me please what is the malfunction?

Wrong type or grade of fuel used. Fault in fuel injection pump. Diagnose and change. Timing of fuel injection pump is incorrect. Adjustment required.

MF 7624 malfunctions. Low engine power. How can I get rid of problem?

Low compression - Have it repaired by the service representative. Poor atomization at nozzle. Service or replace it.

Help anybody what is fault if diesel engine stops suddenly?

Air filter element restricted. Defective fuel injection pump. Cylinder bore worn.

7624 tractor problem. Transmission rough shifting. What could it be?

Excess amount of lubricant - Drain to level of filler plug.

Please give me information why my steering wheel turns around without resistance? What do I need to do to fix an issue?

Low hydraulic oil level in tank - Pour completely. Steering cylinder has damage - Repair it. Steering pump have worn - Replace pump.

I got a MF 7624 in april. Currently there is damage. Motor not starting. Could somebody help me find a source of failure?

Starter faulty - Need a replacement or overhaul. Dirt in the fuel system - Flush and clean the fuel pipe. Filter element is dirty - Install new filter. Wear piston rings - You need repair.

I have the same tractor. Recently I noticed steering wheel works very badly. Tell me what's issue?

Low hydraulic oil level in tank. Steering pump malfunction. Steering pump broken. Repair tie-rod. Breakage of hydraulic hoses. It is necessary to fix a fault. Power steering pump defect. Check the steering pump. Wear of power steering. Diagnose the power steering.

7624 model issue. Diesel engine is difficult to start. Please help me specify occasion of malfunction. What should I check?

High-speed and idle mixture needles not properly adjusted. Cold start system used incorrectly. Broken or Worn Piston Rings. Valve Leakage/Adjustment Bad. Water mixed in the fuel. Crankcase oil too heavy. Use oil of proper viscosity.

Massey Ferguson 7624 diesel breakdowns. Motor hard starting sometimes. How do i fix damage?

Clogging in fuel tank vent. Air leak on the suction side of the system. Restriction in exhaust pipe. Low voltage - Charge battery. Dirty or faulty injectors. Filter clogged. Incorrect timing.

There was a breakdown of the steering on our tractor. What's a breakdown?

The air was formed in hydraulic system. You should remove air. The minimum hydraulic oil indicator in system. Pour completely. Steering hydraulic cylinder is damaged Check and repair.

I have the exact same tractor. Why diesel motor doesn't start? How could i solve a problem?

Valve timing is wrong - Set a valve timing. Low compression. Worn cylinder bores - Need overhaul. Leaks between seats and valves - Need Removal of leakage.

MF 7624 damages. The engine knocks. what is the trouble?

This is a small residue of engine oil. You should pour this. Engine overheated. Engine overloaded.

I can't figure it out why driving front axle to rattle continuously when tractor run?

Defective gear. You need to install new gears. Bearings have damage. Fit new bearings.

I have this tractor some years. Regularly diesel engine start is very hard. What you need to fix?

Injection nozzle has clog. You should to diagnose injector. Injection pump is not working. Repair injection pump.

I get the same model. Explain to me what reason if differential lock is damaged swiftly? How can I fix it? What should I do?

The diaphragm torn or replace friction clutch discs. Requires repair.

I have Massey Ferguson 7624. Engine will not start. Tell me how can I fix this?

We can assume fuel filter clogged. Otherwise injection pump is improperly adjuste.

Need help. Motor overheating occurs. What is the fault?

Lack of coolant in cooling system - Fill cooling system to proper level. Radiator screen or fins clogged - Clean radiator screen or fins. Excessive load - Reduce load or speed. Broken or misadjusted fan belt - Adjust or replace.

My brother has 7624 tractor. Today he got a crash in the rear axle housing. What problem tell me?

These sounds denote destruction of bearings.

Please explain me what happened if engine excessive white smoke at idle?

When white gas appeared from the exhaust pipe you necessary to change piston rings immediately. Incorrect injection timing - Adjust correctly.