________________________________________________________________________________

MF 6270 - Problem solving tips

The day before I found out the damage on my MF 6270. Diesel will not crank. Tell me please what is the probable breakdown?

Fuel type is wrong. The injection pump is broken. Diagnose and change. Wrong fuel pump timing. Perform adjustment.

Massey Ferguson 6270 failures. Engine low on power. How do I troubleshoot it?

Governor linkage out of adjustment. Insufficient compression. Replace cylinder liner or piston rings. Low engine compression.

Help with the question what is defect if diesel engine runs irregularly?

Lack of fuel - Fill the tank and bleed the fuel system. Worn, stuck, or broken piston rings.

6270 model problem. Transmission shifts hard in reverse. What's fault?

Failure to fully depress clutch pedal when shifting - Instruct driver.

Somebody help me why steering wheel spinning very easy? How do I act to get rid of problem?

The minimum oil level - Top up the oil. Steering cylinder has damage - Change the seal. Steering pump have worn - Check the steering pump.

I purchased a MF 6270 in september. Nowadays there is problem. Engine not starting. Can someone help me define the cause of breakdown?

Starter faulty - Check starter and replace if necessary. Fuel line is clogged up - Wash and clean the fuel line. Filter element is dirty - Change it. Wear piston rings - Refit a new set of piston rings.

I use the same model. Recently, steering wheel turns hard. Help me find out what is problem?

Minimum Oil Rating. Bearing stuck - Replace or repair. Clogged suction filter - Remove and clean. hydraulic connection leaking. Eliminate a damage. Pump of power steering is broke. Check the steering pump. Power steering has a defect. Replace it.

6270 tractor problem. Diesel hard starting. Help me please define the reason of failure. What can I do?

Stale or dirty fuel. Empty fuel tank and refill tank with fresh, clean diesel fuel. Cold start system worked incorrectly. Wear or deformation of piston rings. Valve Leakage/Adjustment Bad. Water in fuel. Crankcase oil too heavy. Use oil of proper viscosity.

Massey Ferguson 6270 diesel failures. Diesel motor long starting permanently. How can i fix a failure?

Restriction in fuel tank vent. Air in fuel system. Restriction in exhaust pipe. Low voltage - Charge battery. Dirty or faulty injectors. Clogged fuel filter. Clean or replace fuel filter. Incorrect timing.

Steering does not work on our tractor. What repairs should I do?

The air is in hydraulic system. You need release air from system. Low oil rate in the tank. Top up the oil. Steering cylinder has a defect Replace the faulty part.

Having used the exact same model. Why engine failure to start? How can i fix a failure?

Wrong valve timing - Make adjustment. Low compression. Wear cylinder bores - You must fix it. Leakage between seats and valves - Eliminate leakage.

MF 6270 issue. This is the engine knock. what could be the problem?

This is a small residue of engine oil. You should pour this. Engine overheated. Engine overloaded.

I can not understand why driving front axle to howls chronically at the moment of motion?

Teeth of gears broke. Replace gears. ball bearings crumbled. Replace it.

I own this model about 4 years. Recently, motor start is difficult. What you need to fix?

Injection nozzle is dirty. You must to check injector. High-pressure fuel pump has a breakdown. Replace fuel pump.

I get the exact same model. Tell me what reason if differential lock assembly is defective immediately? What's solution to the problem?

The diaphragm torn or disks of the friction clutch are worn out. You have to make repairs.

I'm using Massey Ferguson 6270. Motor not working. I need to know what is problem?

We can assume fuel filter clogged. Or injection pump adjustment is not correct.

I have the problem. Motor constantly overheats. What is the fault?

Lack of coolant - Refill with coolant. Cooling fins plugged. Crankcase low on oil. Lack of coolant - Refill with coolant. Leaks in system - Replace/tighten hoses and connections. Excessive load - Reduce load or speed. Loose or defective fan belt - Replace fan belt as required. Check belt tensioner.

My dad uses 6270 tractor. Yesterday he heard a strange noise in the rear axle housing. What problem tell me?

All symptoms denote defect in the axle reducer.

Help with the question what damage if diesel engine white exhaust smoke?

If white smoke comes out of the exhaust pipe you necessary to replace piston rings immediately. Piston ring and cylinder worn or stuck - Repair or replace.