________________________________________________________________________________

New Holland TS6.140 - Problem Solving

The other day I noticed a breakdown with my New Holland TS6.140. Diesel does not crank. Tell me please what could be the malfunction?

Fuel type is incorrect. Broken drive on fuel injection pump. Diagnose and change. Wrong fuel pump timing. Adjust as required.

TS6.140 tractor issues. Engine loses power. How do I troubleshoot it?

Engine overheating. Intake and / or exhaust valves leaking. Check valve clearance and sealing effectiveness. Service as required.

Tell me what is damage if diesel engine stops suddenly?

Choke or throttle cable sticking. Improper fuel. Engine control unit or speed sensor faulty.

NH TS6.140 tractor trouble. Hard shifting transmission. What's the reason?

Front bearing retainer loose or cracked - Tighten or replace retainer.

Please tell me why my steering wheel spinning not resisting? How do I act for troubleshooting?

Low hydraulic oil level in the tank - Pour full. Steering cylinder has damage - Replace the defective part. Pump steering broke - Check the steering pump.

I bought a New Holland TS6.140 in september. Presently there is breakdown. Engine won't start. Could anyone help me diagnose a source of problem?

Starter speed is slow - Change or restore. Clogging in the fuel line - Flush and clean the fuel pipe. Fuel filter is dirty - Replace it. Worn piston rings - Replace the piston rings.

I use the same model. Recently, steering wheel is hard to turn. Somebody tell me what's malfunction?

Low Oil Rating. Pour completely. Oil flows out of the system. It is necessary to fix a fault. Pump of power steering is broke. Replace the pump. Power steering is worn out. Replace it.

NH TS6.140 tractor problem. Motor hard starting. Need help to find prime cause of damage. What should I do?

Dirty air filter. Clean/replace air filter. Dirty fuel filter. Replace fuel filter. Incorrect functions of the cold start system. Piston rings are worn or broken. Cracked injector Body or Cup. Water, dirt, or air in fuel system. Drain, flush, fill and bleed system. Fuel too heavy at low temperature.

New Holland TS6.140 diesel motor malfunctions. Engine long starting regularly. How can i fix a failure?

Restricted Fuel Lines. Air leakage to the fuel inlet. Clogging in exhaust pipe. Low voltage - Charge battery. Diesel injection nozzles faulty or sticking. Clogged fuel filter. Clean or replace fuel filter. Incorrect timing.

Steering does not operate on our tractor. How can I fix it?

Hydraulic system has a large amount of air. You must remove air. Oil small indicator in system. Pour completely. Wear of the hydraulic steering cylinder Check and repair.

I have the same tractor. Why engine does not start? How could i resolve the question?

Wrong valve timing - Adjust valve timing. Compression increase. Cylinder bores wear - Repair it. Leakage between valves and seats - Need Removal of leakage.

NH TS6.140 malfunctions. Diesel engine knocks. what kind of failure?

Lack of oil. Add oil. Coolant temperature dropped.

Please help to understand why front axle to howls constantly during operation?

Defective gear. Replace gears. ball bearings have damage. Swap the replacement.

I own this model less than five years. Recently, engine start is difficult. How to get rid of this?

Injector is dirty. You should to check injector. The fuel pump is damaged. Requires replacement of high-pressure fuel pump.

I get the exact same model. Explain to me what's problem if differential lock is damaged swiftly? How can I fix it? What should I do?

Diaphragm worn out or replace friction clutch discs. Requires repair.

I have New Holland TS6.140. Engine not working. I need to know how can I fix this?

Most likely fuel filter clogged. Or injection pump to lost adjustments.

I have the problem. Motor overheats regularly. How to fix it?

Lack of coolant - Refill with coolant. Temperature thermostat is out of order, or insufficient coolant in tank. Check and replace the thermostat or replenish coolant. Engine overloaded. Shift to lower gear or reduce load. Loose or defective fan belt - Replace fan belt as required. Check belt tensioner.

My father has TS6.140 tractor. Yesterday he got a crunch in the rear axle. What's wrong?

These signs evidence of bearing problems.

Help with the question what is fault if motor excessive white smoke at idle?

If white smoke visible from exhaust pipe you necessary to carry out replacement of piston rings immediately. Insufficient fuel delivery. Shortage of or faulty fuel.