________________________________________________________________________________

Kubota L5240 Problems

Lately I got some problem on my L5240 tractor. Diesel can not crank over. Tell me what kind of issue?

Fuel grade is wrong. Fault in fuel injection pump. Check and repair. Wrong fuel injection pump timing. Perform adjustment.

Kubota L5240 malfunctions. The engine fails to develop the full power. How can I fix an issue?

Clogged air cleaner - Clean the element. Filtering element of fuel fine filter is clogged. Replace filtering element.

Help with the question what is the reason that engine runs unevenly?

Air filter element restricted. Defective fuel injection pump. Cylinder bore worn.

L5240 tractor issue. Transmission shifts hard in reverse. What happened?

Transmission misaligned - Correct alignment.

Somebody help me why steering wheel rotates too easy? What do I need to do to troubleshoot?

The minimum oil level - It is required to add oil. The steering cylinder is heavily worn - Make a replacement. Steering pump have worn - Replace pump.

I got a Kubota L5240 in march. Nowadays there is damage. Motor won't start. Could someone help me diagnose a source of problem?

Starter faulty - Check starter and replace if necessary. Clogging in the fuel line - Wash and clean the fuel line. There is dirt in the fuel filter - Change it. Worn piston rings - Install new piston rings.

I have the same tractor. Recently I noticed the steering stopped working. Tell me what's issue?

The minimum oil level. Air in steering hydraulic system. Air-bleed steering system. Bent spindle arm. hydraulic connection leaking. Eliminate the problem. Power steering pump defect. Replace the pump. Power steering is worn out. Diagnose the power steering.

L5240 tractor issue. Diesel engine is difficult to start. Need help to find the reason of malfunction. What can I do?

Improper engine oil viscosity. Loose electrical connections. Cold start system used incorrectly. Damage or wear of piston rings. High pressure fuel pump drive shaft is broken. Water mixed in the fuel. Fuel too heavy at low temperature.

Kubota L5240 diesel engine problems. Engine hard to start permanently. How could i fix this defect?

Restricted Fuel Lines. Air leaks on suction lines. Clogging in exhaust pipe. Slow starter speed. Dirty or faulty injectors. Clogged fuel filter. Clean or replace fuel filter. Fuel shut-off valve closed. Open fuel shut-off valve.

There was a malfunction of steering on my tractor. How can I fix it?

The hydraulic system has air. We recommend you draw out air. Hydraulic oil small indicator in the tank. It is required to add oil. Steering hydraulic cylinder is damaged Change the seal.

I use the same tractor. Why motor has not been started? How can i fix the breakdown?

Valve timing is improper - Adjust valve timing. Compression increase. Worn cylinder bores - Need overhaul. Leakage between valves and seats - Need Removal of leakage.

L5240 tractor damages. This is a diesel motor knock. what kind of damage?

Lack of oil. You should pour this. Coolant temperature is low.

I have a problem why front axle is cracking constantly during operation?

This is the failure of any gear. You must change the gears. Roller bearings crumbled. Fit new bearings.

I have this tractor about 4 years. Recently, engine start is very difficult. How to eliminate?

Nozzle is clogged. You must to check a nozzle. The fuel pump does not work. Repair high-pressure fuel pump.

I have the same tractor. Can someone explain to me what reason if differential lock broke down suddenly? What's solution to the problem?

The diaphragm torn or discs friction clutch worn out. Requires repair.

We have a Kubota L5240. Engine does not start. Help me How can I eliminate a breakdown?

Most likely Dirt in the fuel system. Otherwise the fuel pump not adjusted.

I have the problem. Diesel overheats regularly. What kind of malfunction?

Coolant level lowered. Pour liquid into radiator to recommended level. Radiator screen or fins clogged - Clean radiator screen or fins. Too much load - you must reduce the load or speed. Loose or defective fan belt - Replace fan belt as required. Check belt tensioner.

My friend has Kubota L5240. Today he heard a loud knocking in the crankcase of the drive axle. Which part is damaged?

These symptoms denote destruction of bearings.

Please explain me what is the reason that motor white exhaust smoke?

When white smoke comes from exhaust pipe you need to replace piston rings immediately. Piston ring and cylinder worn or stuck - Repair or replace.

KUBOTA TRACTORS TROUBLESHOOTING
L235	L2501	L2550	L275	L3110
L3301	L35	L3710	L3901	L4310
L5030	M4700	M5700	M6040	M6800
M8200	M8540	M9000	MX5100	MX5200