________________________________________________________________________________
New Holland 7630 - Adjustments and service
The day before I recognized the damage with my New Holland 7630. Diesel
motor will not crank. Tell me what kind of damage?
Fuel type is incorrect. Fuel pump not working. Inspect and replace.
Incorrect fuel injection pump timing. Need to set up.
NH 7630 problems. Engine lacks power. How should I fix an issue?
Remove and clean Air Filter. Remove and clean Muffler or replace.
Restricted air filter. Insufficient fuel flow or quality.
Help with the question what is damage if engine does not run smoothly?
Check compression and vacuum. Electric fuel pump not operating - Replace
fuse.
7630 tractor problem. Transmission shift hard at low speeds. What's
fault?
Defective or worn clutch - Change worn parts.
Here is my question - why steering wheel rotates not resisting? What are
my actions to correct the situation?
Low oil index - Pour completely. Steering cylinder has damage - Make a
replacement. Steering pump have worn - Repair pump.
I bought New Holland 7630 in february. Now there is problem. Motor not
starting. Could someone help me determine the cause of breakdown?
Starter turns bad - Change or restore. Restriction in a fuel pipe -
Flush and clean the fuel pipe. Filter element is dirty - Change the
filter. Wear piston rings - Must be repaired.
I use the same model. Yesterday I saw steering wheel operate heavy. Help
me find out what's issue?
Minimum Oil Rating. Defective steering units pump. Improper toe-in. The
front wheels are not aligned correctly. Oil flows out of the system. It
is necessary to eliminate a fault. Steering pump is worn out. Repair the
pump. Power steering has a defect. Replace it.
7630 model problem. Diesel motor hard to start. Help me specify main
cause of trouble. What can I do?
Fuel inlet needle sticking to seat. Fuel pump dirty or out of
adjustment. Cold start system used incorrectly. Broken or Worn Piston
Rings. Defective fuel pump drive shaft. Water mixed in the fuel.
Crankcase oil too heavy. Use oil of proper viscosity.
NH 7630 diesel issues. Diesel motor is difficult to start sometimes. How
can i resolve the question?
Restriction in fuel tank vent. Air leaks on suction lines. Exhaust pipe
is clogged. Low voltage - Charge battery. Diesel injection nozzles
faulty or sticking. Filter clogged. Incorrect timing.
There was a breakdown of the steering on our tractor. Why did this
happen?
The air is in hydraulic system. You must release air from system. The
minimum oil level in system. Pour completely. Steering cylinder has a
defect Repair it.
Having used the exact same model. Why diesel motor does not start? How
can i fix this defect?
Wrong valve timing - Make adjustment. Bad cylinder compression. Cylinder
bores wear - Repair it. Leaks between valves and seats - Need Removal of
leakage.
7630 tractor troubles. I hear a diesel engine knocking. what kind of
trouble?
Lack of oil. Add oil. Cooling temperature is minimum.
I can't find the reason why driving front axle is cracking chronically
while driving?
This is gears damage. You need to install new gears. Bearings have
damage. You need to change it.
I have this model less than five years. Regularly motor start is
intermittent. How to get rid of this?
Nozzle has clog. It is required to inspect injector. High-pressure fuel
pump has a malfunction. Install a new injection pump.
I get the exact same model. Answer my question why differential lock
does not work swiftly? How to solve the problem?
The diaphragm torn or disks of the friction clutch are worn out. You
have to make repairs.
I have NH 7630. Diesel engine not working. I need to know what is
problem?
We can assume fuel filter clogged. Otherwise high-pressure fuel pump not
adjusted.
Please help. Motor overheats regularly. How can I fix it?
Little coolant in the cooling system. You need to fill the system. Water
pump is broken or its drive belt is too loose, resulting in water
overheating. Check and adjust. Water temp. Gauge not working - Check and
faulty replace. Engine overloaded - Reduce engine load. Loose or problem
fan belt. Adjust belt tension.
My friend has New Holland 7630. Two days ago he diagnosed a noise in the
rear axle. What is the malfunction?
All symptoms denote damaged bearings.
Can someone say me what happened if diesel engine exhaust white gas?
If white smoke comes from the exhaust pipe you required to change piston
rings urgently. Incorrect injection timing - Adjust correctly.
________________________________________________________________________________
- ALL MODELS
- NH T3040 - Operation and maintenance
- NH T4.100 - Operation and overhaul
- NH T4.120 - Operation and repair
- NH T4.55 - Operation and service
- NH T4.75 - Operation and servicing
- NH T4.90 - Operation and troubleshooting
- NH T4.95 - Operation problems
- NH T4030 - Operational issues
- NH T5.120 - Operational questions
- NH T5070 - Overhaul and adjustment
- NH T6.175 - Overhaul and service
- NH T6020 - Overhaul and servicing
- NH T6030 - Overhaul issues
- NH T6050 - Overhaul questions
- NH T6060 - Owners questions
________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________