________________________________________________________________________________

New Holland T6020 - Overhaul and servicing

Yesterday I discovered some problem on my New Holland T6020. Engine can not turn over. Explain me what kind of problem?

Wrong type or grade of fuel used. Drive high pressure fuel pump is broken. Inspect and refit. Incorrect fuel pump timing. Need to set up.

NH T6020 failures. Low engine power. How do I solve the problem?

Compression leak - Replace head gasket, tighten cylinder head screw, glow plug and nozzle holder. Engine not broken-in.

Help with the question what is the reason that diesel engine starts but stops after a short period of time?

Air filter element restricted. Defective fuel injection pump. Cylinder bore worn.

T6020 tractor problem. Transmission shift hard at low speeds. What's fault?

Defective or worn clutch - Change worn parts.

Please give me information why my steering wheel turns around not resisting? What are my actions to troubleshoot?

Minimum Oil Rating - Fill the tank. Steering cylinder has a defect - Repair it. The steering pump is defective - Install a new pump.

I got a New Holland T6020 in july. Now there is malfunction. Motor will not start. Could someone help me find a source of malfunction?

Starter speed is slow - Change or refit. Fuel line is clogged up - Wash and clean the fuel line. Dirty fuel filter element - Change it. Piston rings are broken - Must be repaired.

I bought the same tractor. Recently, steering wheel turns tight. Tell me what are possible malfunctions?

Low hydraulic oil level in tank. It is required to top up the oil. Oil flows out of the system. It is necessary to fix the problem. Pump of power steering is broke. Check the steering pump. Wear of power steering. Install the new power steering.

T6020 tractor problem. Diesel cranks but will not start. Please help me specify the cause of breakdown. What do I need to check?

Engine valves out of adjustment. Contact an authorized service center. Cold start system worked incorrectly. Piston rings are worn or broken. Valve Leakage/Adjustment Bad. Water, dirt, or air in fuel system. Drain, flush, fill and bleed system. Fuel too heavy at low temperature.

NH T6020 motor breakdowns. Motor is difficult to start sometimes. How do i fix a failure?

Restricted Fuel Lines. Air in fuel tank. Bleed fuel tank. Exhaust pipe is clogged. Slow starter speed. Diesel injection nozzles faulty or sticking. Filter clogged. Long Idle periods.

There was a breakdown of the steering on my tractor. Why did this happen?

The air is in hydraulic system. You need release air from system. Small level of oil in the tank. Pour completely. Steering cylinder has a defect Replace the faulty part.

I use the exact same model. Why diesel doesn't start? How could i fix a failure?

Valve timing is wrong - Need setting of valve timing. Compression increase. Cylinder bores wear - Need overhaul. Leakage between seats and valves - Remove leakage.

T6020 tractor malfunctions. Diesel engine knocks. what is the probable malfunction?

This is a small residue of engine oil. Fill with oil. Coolant temperature is low.

I can't find the reason why front axle produces a rumble chronically while driving?

This is gears damage. It is recommended to replace the gear. Roller bearings crumbled. Replace it.

I'm the owner this model three years. Regularly motor start is difficult. How to eliminate?

Nozzle is dirty. You should checking a nozzle. Injection pump is not working. Do overhaul of fuel pump.

I get the exact same tractor. Tell me why differential lock breaks down suddenly? What's solution to the problem?

Diaphragm worn out or wear of discs friction clutch. Replace parts.

I'm using New Holland T6020. Diesel engine not working. Tell me how can I fix this?

Probably fuel filter element has dirt. Otherwise high-pressure fuel pump is improperly adjuste.

Need help. Engine overheating occurs. What is the problem?

Little coolant in the cooling system. You need to fill the system. Engine oil low or too high. Engine operated too long at slow engine speed. Thermostat sticking or inoperative. Too much oil in crankcase. Diesel Overload - Reduce diesel load. Loose or problem fan belt. Adjust belt tension.

My father has NH T6020. Today he got knocking in the rear axle. What's wrong?

These symptoms denote destruction of bearings.

Please explain me what is problem if engine white exhaust smoke?

When white smoke comes out of the exhaust pipe you must to carry out replacement of piston rings immediately. Clogged air cleaner - Clean or replace elements.