________________________________________________________________________________

New Holland 7740 - Adjustments and servicing

Two days ago I found out a malfunction with my New Holland 7740. Motor doesn't crank over. Tell me please what is the failure?

You used an incorrect type of fuel. The fuel pump drive is faulty. Check and overhaul. Wrong fuel injection pump timing. Adjustment required.

NH 7740 damages. Engine has low power or compression. How can I get rid of problem?

Improper fuel. Insufficient compression or leaking valves. Operating temperature too low - Bring up to correct operating temperature.

Please explain me why diesel engine runs unevenly?

Seized engine due to lack of oil, the wrong oil or lack of coolant.

7740 tractor trouble. Transmission shift hard at low speeds. What happened?

Failure to fully depress clutch pedal when shifting - Instruct driver.

Here is my question - why my steering wheel turns around without opposition? How do I act to troubleshoot?

Minimum Oil Rating - It is required to top up the oil. Possible malfunction steering hydraulic cylinder - Make a replacement. Pump steering broke - Check the steering pump.

I purchased a New Holland 7740 in september. Now there is trouble. Diesel will not start. Can somebody help me define a source of problem?

Starter rotates slowly - Need a replacement or overhaul. Fuel line is clogged up - Clean and flush. The fuel filter element is dirty - Replace it. Piston rings worn out - You need repair.

I have the same tractor. Recently I noticed steering wheel turns tight. Help me find out what is problem?

Low oil index. Fill the tank. Hydraulic connections are not sealed. Eliminate the problem. Power steering pump defect. Check the steering pump. Power steering is worn out. Install the new power steering.

7740 tractor question. Motor very hard starting. Need help to recognize prime cause of breakdown. What do I need to check?

In winter, oil viscosity increases, and engine cranks slowly. Incorrect functions of the cold start system. Defect or failure of piston rings. Injection pump drive shaft is defective. Water in fuel. Fuel too heavy at low temperature.

NH 7740 diesel engine problems. Motor hard starting regularly. How could i fix damage?

Clogging in fuel tank vent. Air leak on the suction side of the system. Restriction in exhaust pipe. Slow starter speed. Injection fuel is little or the spray is not excellent. Filter clogged. Long Idle periods.

Steering doesn’t function on our tractor. Why did this happen?

The hydraulic system has air. You should draw out air. Low oil rate in the tank. Fill the tank. Steering hydraulic cylinder worn out Make a replacement.

Having used the exact same tractor. Why engine has not been started? How do i fix damage?

Improper valve timing - Need setting of valve timing. Bad compression. Wear cylinder bores - Need overhaul. Leakage between seats and valves - Remove leakage.

NH 7740 breakdowns. Diesel engine knocks. what is the probable damage?

This is a small residue of engine oil. Fill with oil. Low engine speed. Oil level low.

Please help to understand why front axle to rattle regularly at the moment of motion?

Defective gear. It is recommended to replace the gear. ball bearings are firmly erased. Fit new bearings.

I own this tractor about 5 years. Sometimes diesel engine start is difficult. What you need to fix?

Injector is dirty. You must to diagnose injector. Injection pump does not work. Requires replacement of fuel pump.

I bought the same model. Explain to me what reason if locking differential is damaged immediately? What's solution to the problem?

Diaphragm damaged or replace friction clutch discs. Requires repair.

I'm using 7740 tractor. Diesel engine does not start. Tell me what's issue?

Possibly fuel filter element has dirt. Otherwise the fuel pump to lost adjustments.

Need help. Engine constantly overheats. How to fix it?

Low coolant level - Fill coolant and check cooling system for loose connections or leak. Radiator is dirty - Clean it. Diesel Overload - Reduce diesel load. Broken or misadjusted fan belt - Adjust or replace.

My dad uses New Holland 7740. Today he heard a crunch in the crankcase of the drive axle. What problem tell me?

These sounds evidence of defect in the axle reducer.

Please explain me what is fault if engine emits white smoke?

If white gas appeared from the exhaust pipe you must to replace piston rings immediately. Air filter blocked. Clean or replace as per maintenance schedule.