________________________________________________________________________________

New Holland T6040 - Problems and repair

Recently I recognized some problem on my New Holland T6040. Diesel engine will not turn over. Tell me what could be the breakdown?

Fuel grade is wrong. The fuel pump drive is faulty. Inspect and refit. Timing of fuel injection pump is incorrect. Adjustment required.

NH T6040 failures. The engine fails to develop the full power. How do I solve the problem?

Low compression - Have it repaired by the service representative. Poor atomization at nozzle. Service or replace it.

Help anybody what is problem if engine does not run smoothly?

Insufficient fuel supply - Top up fuel and air-bleed fuel system. Wrong valve clearance.

T6040 model problem. Transmission shifts hard. What could it be?

Wrong transmission lubricant - Drain and fill with recommended lubricant.

Please give me information why my steering wheel turns too easy? What should I do to correct the situation?

Low hydraulic oil level in tank - It is required to add oil. Steering cylinder has problems - Make a replacement. Defect in the power steering pump - Check the steering pump.

I acquired New Holland T6040 in march. Nowadays there is problem. Diesel motor not starting. Can anybody help me define a source of breakdown?

Starter does not work - Change or restore. Fuel pipes are contaminated - Flush and clean the fuel pipe. There is dirt in the fuel filter - Change the filter. Piston rings worn out - Must be repaired.

I have the same tractor. Recently I noticed steering wheel operate heavy. Help me find out what are possible malfunctions?

Minimum Oil Rating. The front wheels are not aligned correctly. Steering gear not properly adjusted (too tight). Hydraulic connections are not sealed. It is necessary to eliminate a defect. Steering pump is worn out. Check the steering pump. Power steering defective. Replace it.

T6040 tractor problem. Diesel hard starting. Please help me recognize the reason of issue. What can I do?

Loose or corroded electrical connections. Plugged fuel filter. Remove Air Filter and clean. Incorrect functions of the cold start system. Damage or wear of piston rings. Cracked injector Body or Cup. Water in fuel. Fuel too heavy at low temperature.

NH T6040 diesel engine breakdowns. Diesel long starting sometimes. How could i fix the breakdown?

Restricted Fuel Lines. Air in fuel tank. Bleed fuel tank. Exhaust pipe is clogged. Low voltage - Charge battery. Injection fuel is little or the spray is not excellent. Clogged fuel filter. Clean or replace fuel filter. Fuel shut-off valve closed. Open fuel shut-off valve.

Steering stopped working on our tractor. What is problem?

The air was formed in hydraulic system. You must draw out air. Hydraulic oil small indicator in system. Top up the oil. Steering hydraulic cylinder is damaged Check and repair.

I have the exact same model. Why diesel doesn't start? How could i fix damage?

Valve timing is improper - Make adjustment. High or Low compression. Worn cylinder bores - Repair it. Leaks between valves and seats - Eliminate leak.

New Holland T6040 issues. I hear a diesel knock. what could be the failure?

Lack of oil. Fill with oil. Engine out of time. Excessive engine load.

I can't figure it out why tractor front axle to howls continuously while driving?

Teeth of gears collapsed. You must change the gears. Roller bearings are very worn out. Fit new bearings.

I own this model some years. Regularly engine start is very difficult. What a breakdown?

Nozzle has clog. You must to inspect injector. The fuel pump is not working. Replace injection pump.

I bought the same model. Can someone explain to me what's problem if locking differential does not work swiftly? How to solve the problem?

Diaphragm damaged or wear of discs friction clutch. You have to make repairs.

I have NH T6040. Diesel engine not starting. I need to know what is the fault?

Probably Dirt in the fuel system. Or the fuel pump to lost adjustments.

I have the problem. Diesel constantly overheats. What is the fault?

Low coolant level. Fill radiator to proper level, check radiator, coolant recovery tank, and hoses for loose connection or leaks. Clogged radiator - Clean the core. Diesel Overload - Reduce diesel load. Fan belt is damaged. Change as required.

My father has T6040 tractor. Three days ago he heard a crunch in the rear axle. What's wrong?

All signs talk about bearing problems.

Can someone say me what is fault if diesel engine white exhaust smoke?

If white smoke visible from exhaust pipe you required to replace piston rings immediately. Excessive engine oil - Reduce to specified level.