________________________________________________________________________________

New Holland TM120 - Service and overhaul

A week ago I recognized the problem on my NH TM120. Motor can not rotate. Tell me what is the problem?

Wrong type or grade of fuel used. The fuel pump drive is faulty. Check and repair. Timing of fuel injection pump is incorrect. Need to set up.

New Holland TM120 breakdowns. Insufficient engine power. How to troubleshoot it?

Clogged air cleaner - Clean the element. Filtering element of fuel fine filter is clogged. Replace filtering element.

Can someone say me what is problem if engine runs but misses?

Air filter element plugged or oil soaked. Dirt or water in fuel system.

TM120 tractor trouble. Transmission shifts hard. What happened?

Shift quadrant not properly adjusted. Worn shifter lever assembly.

Somebody help me why steering wheel rotates without resistance? What are my actions to get rid of problem?

Minimum Oil Rating - Pour completely. This is a steering cylinder malfunction - Perform repair. Defect in the power steering pump - Repair pump.

I acquired a NH TM-120 in march. Today there is failure. Diesel engine not starting. Could anyone help me find the cause of trouble?

Starter turns bad - Replace or repair. Fuel line is clogged up - Wash and clean the fuel line. Fuel filter is dirty - Replace fuel filter. Piston ring failure - Must be repaired.

I bought the same tractor. Recently, steering does not work well. Somebody tell me what's malfunction?

Low oil index. Incorrect toe-in. Improper alignment of front wheels - Replace tie-rod. Leak in hydraulic connections. It is necessary to fix a defect. Steering pump is worn out. Repair the pump. Power steering defective. Diagnose the power steering.

TM-120 tractor trouble. Diesel engine is hard to start. Help me diagnose the reason of failure. What should I check?

Improper engine oil viscosity. Loose electrical connections. Cold start system used incorrectly. Broken or Worn Piston Rings. Defective fuel pump drive shaft. Water mixed in the fuel. Crankcase oil too heavy. Use oil of proper viscosity.

New Holland TM120 diesel engine damages. Diesel long starting regularly. How do i fix this defect?

Restriction in fuel tank vent. Air Leaks in Suction Lines. Restriction in exhaust pipe. Slow starter speed. Diesel injection nozzles faulty or sticking. Filter clogged. Fuel shut-off valve closed. Open fuel shut-off valve.

There was a malfunction of steering on our tractor. What repairs should I do?

Hydraulic system has a large amount of air. You need remove air. The minimum hydraulic oil indicator in system. Pour completely. Steering cylinder has a defect Repair it.

I use the exact same model. Why diesel motor has not been started? How do i fix the breakdown?

Wrong valve timing - Make adjustment. Compression increase. Cylinder bores wear - Need overhaul. Leaks between seats and valves - Need Removal of leakage.

TM120 tractor issue. Diesel engine knocks. what could be the breakdown?

Oil of small quantity. Add oil. Low engine speed. Oil level low.

I can't figure it out why front axle to make a lot of noise continuously while driving?

Teeth of gears broke. It is recommended to replace the gear. Bearings are very worn out. Swap the replacement.

I'm the owner this model more than 3 years. Recently, diesel starting is very difficult. How to get rid of this?

Injection nozzle has dirt. Need to diagnose injector. Injection pump has a malfunction. Repair fuel pump.

I have the exact same model. Tell me why differential lock broke down swiftly? What's solution to the problem?

Diaphragm damaged or discs friction clutch worn out. Change worn components.

I'm using New Holland TM-120. Diesel engine not starting. Tell me what is problem?

Possibly this is a clogged fuel filter. Otherwise the fuel pump to lost adjustments.

I have the problem. Diesel overheats regularly. What could be the problem?

Little coolant in the cooling system. You need to fill the system. Clogged radiator fins - Clean the radiator fins. Internal wear limits out of specification. Injector timing is too advanced. Adjust as per specification. Diesel Overload - Reduce diesel load. Loose or problem fan belt. Adjust belt tension.

My father has NH TM120. Yesterday he got a crunch in the crankcase of the drive axle. What problem tell me?

These symptoms evidence of bearing problems.

Help with the question what is the reason that engine exhaust white gas?

When white gas appeared from exhaust pipe you required to replace piston rings immediately. Oil level too high - Reduce to correct quantity.