________________________________________________________________________________

New Holland T6090 - Problems and solutions

Lately I discovered a failure with my NH T6090. Motor doesn't rotate. Tell me please what is the damage?

Fuel grade is incorrect. Fuel pump drive problems. Diagnose and change. Incorrect fuel injection pump timing. Need to set up.

New Holland T6090 problems. Engine deficient output. How to correct the situation?

Incorrect fuel injection timing. Injection nozzle faulty or incorrect injection cycle. Insufficient fuel supply - Check fuel system.

Can someone say me what is the reason that engine runs irregularly?

Air in the fuel lines or filter element blocked. Check, bleed air or replace the filter element.

T6090 tractor trouble. Transmission shift hard at low speeds. What happened?

Differential bevel gears worn or damaged. Shifting gears while tractor is in motion.

Somebody help me why steering wheel rotates without resistance? What are my actions to troubleshoot?

The minimum oil level - Fill the tank. This is a steering cylinder malfunction - Perform repair. Steering pump have worn - Replace pump.

I got a NH T6090 in july. Currently there is issue. Motor won't start. Could somebody help me determine the source of issue?

Starter motor turns engine too slowly - Check starter and replace if necessary. Fuel line is clogged up - Clean and wash. Filter element is dirty - Replace it. Piston rings are broken - Replace the piston rings.

I use the same model. Recently, steering does not work well. Somebody tell me what's malfunction?

Low oil index. Tight spindles.Different from tyre inflation - Inflate both tyres to same specified pressure. hydraulic connection leaking. Eliminate the problem. Steering pump is defective. Install the new pump. Power steering is worn out. Install the new power steering.

T6090 model trouble. Diesel very hard starting. Help me please diagnose occasion of breakdown. What should I do?

Choke cable not adjusted properly. Choke not operating properly. Cold start system worked incorrectly. Wear or deformation of piston rings. Defective fuel pump drive shaft. Water, dirt, or air in fuel system. Drain, flush, fill and bleed system. Crankcase oil too heavy. Use oil of proper viscosity.

New Holland T6090 diesel motor problems. Motor starts hard permanently. How can i fix this defect?

Clogging in fuel tank vent. Air leaks on suction lines. Clogging in exhaust pipe. Slow starter speed. Diesel injection nozzles faulty or sticking. Filter clogged. Long Idle periods.

Steering does not operate on my tractor. Why did this happen?

Hydraulic system has a large amount of air. We recommend you remove air. Oil small indicator in the tank. It is required to add oil. Steering hydraulic cylinder worn out Make a replacement.

I own the same tractor. Why diesel engine failure to start? How can i resolve an issue?

Improper valve timing - Adjust valve timing. Bad cylinder compression. Cylinder bores are worn - Need overhaul. Leakage between seats and valves - Remove leakage.

New Holland T6090 failures. Diesel engine knocks. what is the breakdown?

This is a small residue of engine oil. You should pour this. Coolant temperature dropped.

Please help to understand why driving front axle to rattle chronically at work?

Teeth of gears broke. It is recommended to replace the gear. ball bearings are firmly erased. Swap the replacement.

I'm the owner this tractor three years. Sometimes engine start is intermittent. How to eliminate?

Injector is clogged. Need checking a nozzle. Injection pump has a breakdown. Install a new high-pressure fuel pump.

I have the same tractor. Can anybody tell me what reason if differential lock is defective immediately? How can I fix it? What should I do?

This is the diaphragm rupture or discs friction clutch worn out. Change worn components.

I'm using T6090 tractor. Engine will not start. Help me can i fix the problem?

Most likely this is a clogged fuel filter. Otherwise high-pressure fuel pump not adjusted.

Please help me. Engine constantly overheats. How to fix it?

Lack of coolant in cooling system - Fill cooling system to proper level. Clean the radiator from dirt and dust, if necessary, clean cooling system from scale. Adjust the fan belt tension. Detect the faulty injectors, wash, clean and adjust them. Motor overloaded - Reduce motor load. Loose or problem fan belt. Adjust belt tension.

My brother has NH T6090. Two days ago he diagnosed knocking in the crankcase of the drive axle. What problem tell me?

These symptoms evidence of defect in the axle reducer.

Tell me what is defect if motor excessive white smoke at idle?

When white gas comes out of the exhaust pipe you necessary to change piston rings urgently. Piston ring and cylinder worn or stuck - Repair or replace.