________________________________________________________________________________

Ford 1910 Tractor Troubleshooting

The other day I found out some issue on my Ford 1910 backhoe. Motor can not crank over. Tell me please what kind of trouble?

Fuel type is incorrect. Fuel pump drive problems. Diagnose and change. Incorrect fuel injection pump timing. Need to set up.

1910 tractor breakdowns. Low engine power. How to solve the problem?

Low compression - Have it repaired by the service representative. Poor atomization at nozzle. Service or replace it.

Please explain me what happened if diesel engine runs unevenly?

Dirt, water, or ice in fuel system. Jet nozzle clogged - Replace or repair the nozzle.

1910 4WD tractor failure. Hard shifting transmission. What happened?

Wrong transmission lubricant - Drain and fill with recommended lubricant.

I would like to know why my steering wheel turns around without resistance? What do I need to do to solve the problem?

Low Oil Rating - Pour full. Steering cylinder has damage - Replace the defective part. Pump steering broke - Repair pump.

I bought a Ford 1910 with loader in november. Nowadays there is failure. Motor will not start. Can somebody help me find the source of failure?

Starter turns bad - Diagnose starter and reinstall if necessary. Dirt in the fuel system - Flush and clean the fuel pipe. Dirty fuel filter element - Replace it. Worn piston rings - Must be repaired.

I use the same model. Recently, steering wheel works hard. Explain to me what is a breakdown?

The minimum oil level. Tight spindles.Different from tyre inflation - Inflate both tyres to same specified pressure. Oil flows out of the system. Eliminate a fault. Steering pump is defective. Check the steering pump. Power steering is damaged. Replace it.

1910 4WD tractor trouble. Diesel motor hard to start. Need help to specify the cause of problem. What do I need to check?

Engine flooded. Engine oil filter restricted. Water, rust or stale fuel in tank. Incorrect functions of the cold start system. Defect or failure of piston rings. Valve Leakage/Adjustment Bad. Water in fuel. Fuel too heavy at low temperature.

Ford 1910 diesel damages. Motor hard starting permanently. How could i fix a failure?

Clogging in fuel tank vent. Air in fuel tank. Bleed fuel tank. Clogging in exhaust pipe. Low voltage - Charge battery. Dirty or faulty injectors. Filter clogged. Fuel shut-off valve closed. Open fuel shut-off valve.

Steering does not operate on our tractor. What's a breakdown?

The air is in hydraulic system. You need draw out air. The minimum oil level in system. Top up the oil. Steering hydraulic cylinder is damaged Replace the faulty part.

I have the same model. Why engine failure to start? How can i fix the breakdown?

Improper valve timing - Make adjustment. High or Low compression. Worn cylinder bores - Need overhaul. Leaks between seats and valves - Remove leakage.

Ford 1910 malfunctions. This is a diesel motor knock. what could be the issue?

Oil of small quantity. Fill with oil. Engine oil level low. Incorrect fuel - Fill with right fuel.

I have a problem why front axle to howls constantly at the moment of motion?

Gears teeth crumbling. You need to install new gears. Bearings are very worn out. Replace it.

I have this model about 4 years. Often motor start is intermittent. What a breakdown?

Injection nozzle has clog. You should to diagnose injector. Injection pump has a malfunction. Install a new injection pump.

I get the same model. Explain to me why locking differential broke down abruptly? How to solve the problem?

The diaphragm torn or disks of the friction clutch are worn out. You have to make repairs.

We have Ford 1910 front end loader. Diesel engine does not start. Tell me what is problem?

Most likely Dirt in the fuel system. Or the fuel pump to lost adjustments.

Please help. Diesel overheating occurs. What kind of malfunction?

Coolant level lowered. Pour liquid into radiator to recommended level. Cooling fluid boils in the radiator. Poor fuel atomization by the injectors. High-speed and idle mixture needles not properly adjusted. Motor overloaded - Reduce motor load. Broken or misadjusted fan belt - Adjust or replace.

My father has Ford 1910 4WD. Today he diagnosed a crunch in the rear axle. What's wrong?

All sounds evidence of destruction of bearings.

Please explain me why diesel exhaust white gas?

If white gas visible from exhaust pipe you need to change piston rings urgently. Oil level too high - Reduce to correct quantity.

FORD TRACTORS TROUBLESHOOTING
1710	1900	2120	2600	3600
3930	4100	4630	5600	5640
6410	6610	6640	6710	6810
7610	7740	7810	8210	8240
8630	8830	8770	TW30	TW35