________________________________________________________________________________

Ford 4630 Tractor Troubleshooting

The day before I found out a breakdown with my Ford 4630 loader. Diesel motor doesn't turn over. Tell me what is the issue?

Fuel type is wrong. Fuel pump drive problems. Inspect and replace. Wrong fuel injection pump timing. Adjust as required.

4630 tractor breakdowns. Low engine power. How to get rid of problem?

Clogged air cleaner Check the air cleaner. Engine valves out of adjustment. Contact an authorized service department.

Tell me what is defect if diesel engine misses?

Water separator clogged - Clean water separator.

Ford 4630 turbo tractor problem. Transmission shifts hard in reverse. What could it be?

Wrong transmission lubricant - Drain and fill with recommended lubricant.

I would like to know why steering wheel turns not resisting? How do I act to solve the problem?

Low oil index - Top up the oil. This is a steering cylinder malfunction - Replace the defective part. Steering pump have worn - Check the steering pump.

I acquired a Ford 4630 4WD in september. Today there is breakdown. Engine will not start. Could somebody help me determine a source of breakdown?

Starter motor turns engine too slowly - Inspect the starter and install a new as required. Restriction in a fuel pipe - Clean and flush. Filter element is dirty - Change the filter. Piston rings are damaged - Change piston rings.

I use the same tractor. Recently, steering wheel turns bad. Explain to me what's malfunction?

Low hydraulic oil level in the tank. Faulty steering pump. Steering pump malfunction. Tight ball joints. Oil flows out of the system. Eliminate the problem. Pump of power steering is broke. Repair the pump. Hydraulic power steering is defective. Requires repair.

4630 4x4 tractor trouble. Motor very hard starting. Need help to diagnose the reason of trouble. What can I do?

Clogged fuel line or air lock. Dirt or water in fuel system. Cold start system worked incorrectly. Piston rings are wear or deformed. Cracked injector Body or Cup. Water in fuel. Fuel too heavy at low temperature.

Ford 4630 diesel motor malfunctions. Diesel hard to start permanently. How can i solve a problem?

Restriction in fuel tank vent. Air leaks on suction lines. Clogging in exhaust pipe. Slow starter speed. Dirty or faulty injectors. Clogged fuel filter. Clean or replace fuel filter. Incorrect timing.

There was a malfunction of steering on my tractor. What is problem?

The hydraulic system has air. We recommend you remove air. The minimum hydraulic oil indicator in system. It is required to add oil. Steering hydraulic cylinder is damaged Change the seal.

I use the exact same tractor. Why diesel doesn't start? How could i fix the breakdown?

Valve timing is wrong - Make adjustment. Bad compression. Cylinder bores wear - Repair it. Leakage between valves and seats - Remove leakage.

4630 4x4 tractor issue. Diesel engine knocks. what is the probable problem?

This is a small residue of engine oil. Fill with oil. Coolant temperature is low.

I have a problem why driving front axle to make a lot of noise constantly when driving?

Teeth of gears collapsed. You need to install new gears. Roller bearings are firmly erased. Replace it.

I'm the owner this tractor about four years. Recently, motor start is intermittent. What a breakdown?

Nozzle is dirty. You should checking a nozzle. The fuel pump is damaged. Repair fuel pump.

I have the exact same tractor. Can someone explain to me what's problem if differential lock assembly breaks down swiftly? How to solve the problem?

Diaphragm worn out or discs friction clutch worn out. Requires repair.

We have Ford 4630 4WD with a loader. Diesel engine not working. Tell me what is the fault?

Probably fuel filter clogged. Otherwise high-pressure fuel pump to lost adjustments.

Please help me. Motor constantly overheats. How can I repair it?

Lack of coolant - Refill with coolant. Defective thermostat - Replace. Dirty, plugged, or damaged shrouding or engine fins. Insufficient engine oil - Inspect oil level and replenish if necessary. Excessive load - Reduce load or speed. Broken or misadjusted fan belt - Adjust or replace.

My father has Ford 4630 turbo. Two days ago he heard a noise in the rear axle. What's wrong?

All sounds denote damaged bearings.

Tell me what damage if diesel engine exhaust with white smoke?

If white smoke comes from the exhaust pipe you necessary to carry out replacement of piston rings urgently. Injector pump or injectors delivering fuel unevenly. Check and service injectors and injector pump – specialist operation.

FORD TRACTORS TROUBLESHOOTING
1710	1900	2120	2600	3600
3930	4100	4630	5600	5640
6410	6610	6640	6710	6810
7610	7740	7810	8210	8240
8630	8830	8770	TW30	TW35