________________________________________________________________________________

Ford TW30 Tractor Problems

Lately I discovered some problem with my TW30 tractor. Motor does not rotate. Tell me what could be the malfunction?

Fuel grade is wrong. Broken drive on fuel injection pump. Inspect and refit. Incorrect fuel pump timing. Adjust as required.

Ford TW30 troubles. Loss of power. How can I troubleshoot it?

Engine overheating. Intake and / or exhaust valves leaking. Check valve clearance and sealing effectiveness. Service as required.

Please explain me what is fault if diesel engine stalls?

Defective fuel injectors. Fuel injection pump timing. Defective fuel pump. Defective injectors.

TW30 tractor question. Transmission rough shifting. What's fault?

Shifter forks, rods, or other transmission gear selection components damaged.

Please give me information why steering wheel rotates without resistance? How do I act to fix an issue?

Low oil index - Pour full. Steering cylinder has damage - Make a replacement. Pump steering broke - Install a new pump.

I acquired a Ford TW30 in april. Today there is problem. Diesel motor not starting. Could anyone help me diagnose a source of failure?

Starter rotates slowly - Diagnose starter and reinstall if necessary. Restriction in a fuel pipe - Clean and wash. There is dirt in the fuel filter - Replace fuel filter. Piston rings are broken - You need repair.

I use the same tractor. Recently, steering wheel turns hard. Somebody tell me what is problem?

Low oil index. The front wheels are not aligned correctly. Steering gear not properly adjusted (too tight). Hydraulic connections are not sealed. It is necessary to fix a damage. Pump of power steering is broke. Install the new pump. Power steering has a defect. Replace it.

TW30 tractor trouble. Diesel cranks but not starting. Help me please determine the reason of trouble. What needs to be repaired?

Stale or dirty fuel. Empty fuel tank and refill tank with fresh, clean diesel fuel. Cold start system used incorrectly. Wear or deformation of piston rings. Broken Fuel Pump Drive Shaft. Water in fuel. Fuel too heavy at low temperature.

Ford TW30 diesel engine malfunctions. Diesel hard to start regularly. How do i solve a problem?

Restricted Fuel Lines. Air leakage to the fuel inlet. Restriction in exhaust pipe. Low voltage - Charge battery. Dirty or faulty injectors. Clogged fuel filter. Clean or replace fuel filter. Fuel shut-off valve closed. Open fuel shut-off valve.

Steering doesn’t function on my tractor. What is problem?

The air was formed in hydraulic system. You should release air from system. Oil low level in system. Top up the oil. Wear of the hydraulic steering cylinder Check and repair.

I have the same tractor. Why motor does not start? How do i fix the breakdown?

Valve timing is improper - Need setting of valve timing. Low compression. Cylinder bores wear - You must fix it. Leakage between seats and valves - Remove leakage.

TW30 tractor troubles. Diesel engine knocks. what is the probable trouble?

Oil of small quantity. Fill up. Engine oil level low. Incorrect fuel - Fill with right fuel.

I can't figure it out why driving front axle to howls chronically while driving?

Teeth of gears collapsed. You must change the gears. ball bearings are very worn out. Swap the replacement.

I have this model more than 3 years. Recently, engine start is intermittent. What a breakdown?

Injector has clog. It is required checking a nozzle. The fuel pump problems. Install a new fuel pump.

I get the same tractor. Tell me why locking differential breaks down swiftly? What's solution to the problem?

Diaphragm damaged or wear of discs friction clutch. You have to make repairs.

Our company has Ford TW30. Engine will not start. Help me what is the fault?

Possibly fuel filter clogged. Or the fuel pump adjustment is not correct.

I have trouble. Engine constantly overheats. What kind of malfunction?

Lack of coolant - Refill with coolant. Cooling fins plugged. Crankcase low on oil. Lack of coolant - Refill with coolant. Leaks in system - Replace/tighten hoses and connections. Diesel Overload - Reduce diesel load. Loose or fan belt issue - Adjust fan belt and replace if needed.

My brother has TW30 tractor. Two days ago he got a strange noise in the rear axle. What's wrong?

All sounds denote bearing problems.

Help with the question what is fault if diesel engine exhaust with white smoke?

When white gas comes from the exhaust pipe you required to change piston rings urgently. Piston ring and cylinder worn or stuck - Repair or replace.

FORD TRACTORS TROUBLESHOOTING
1710	1900	2120	2600	3600
3930	4100	4630	5600	5640
6410	6610	6640	6710	6810
7610	7740	7810	8210	8240
8630	8830	8770	TW30	TW35