________________________________________________________________________________

Ford 6410 Tractor Problems

A week ago I recognized some trouble on my 6410 4WD tractor. Diesel engine can not crank. Tell me what is the damage?

You used an incorrect type of fuel. Possible failure drive high pressure fuel pump. Check and repair. Incorrect fuel injection pump timing. Adjust if necessary.

Ford 6410 issues. Poor engine performance. How can I correct the situation?

Air cleaner element is clogged. Air filter contaminated - Clean air filter. Deficient nozzle injection - Repair or replace nozzle.

Help with the question why engine does not run smoothly?

Airlock in fuel line. Fuel-line is leaking air - Retighten clamps, replace defective pipes.

6410 tractor question. Transmission rough shifting. What happened?

Linkage binding, bent, or loose - Free, straighten, or tighten as needed.

Here is my question - why steering wheel turns without resistance? How do I act to get rid of problem?

Minimum Oil Rating - Top up the oil. Possible malfunction steering hydraulic cylinder - Replace the defective part. Steering pump have worn - Replace pump.

I got a Ford 6410 4WD in march. Nowadays there is trouble. Diesel won't start. Can someone help me define a source of failure?

Starter faulty - Need a replacement or overhaul. Fuel pipes are contaminated - Clean and flush. Fuel filter is dirty - Replace it. Wear piston rings - Need replacement of piston rings.

I use the same model. Yesterday I saw steering wheel is hard to turn. Explain to me what is a breakdown?

The minimum oil level. Top up the oil. Leak in hydraulic connections. Eliminate a damage. Pump of power steering is broke. Check the steering pump. Power steering defective. Replace it.

6410 tractor issue. Diesel hard starting. Help me please diagnose the reason of problem. What do I need to check?

Air or water in the fuel system. Battery is discharged. Recharge or replace battery. Cold start system worked incorrectly. Wear or deformation of piston rings. Valve Leakage/Adjustment Bad. Water in fuel. Crankcase oil too heavy. Use oil of proper viscosity.

Ford 6410 diesel malfunctions. Diesel long starting permanently. How can i fix damage?

Restriction in fuel tank vent. Air leakage to the fuel inlet. Restriction in exhaust pipe. Slow starter speed. Dirty or faulty injectors. Filter clogged. Long Idle periods.

There was a malfunction of steering on my tractor. How can I fix it?

The air was formed in hydraulic system. You should remove air. Small level of oil in system. Top up the oil. Steering cylinder has problems Make a replacement.

I am working on the same tractor. Why diesel has not been started? How do i fix damage?

Valve timing is incorrect - Set a valve timing. Compression increase. Cylinder bores are worn - Need overhaul. Leakage between valves and seats - Need Removal of leakage.

Ford 6410 damages. This is a diesel motor knock. what is the probable damage?

Oil of small quantity. Fill with oil. Coolant temperature is low.

I have a problem why front axle is cracking chronically at the moment of motion?

Gears teeth crumbling. You must change the gears. ball bearings are very worn out. Fit new bearings.

I'm the owner this tractor three years. Regularly engine start is difficult. What a breakdown?

Injector has dirt. Need to inspect a nozzle. Injection pump has a malfunction. Requires replacement of fuel pump.

I have the same tractor. Can anybody tell me what's problem if locking differential can break immediately? How can I fix it? What should I do?

The diaphragm torn or wear of discs friction clutch. You have to make repairs.

I'm using 6410 tractor. Diesel engine not starting. Tell me how can I fix this?

Probably Dirt in the fuel system. Or the fuel pump is improperly adjuste.

Need help. Motor overheats regularly. How can I repair it?

Lack of coolant in cooling system - Fill cooling system to proper level. Defective thermostat - Replace. Dirty, plugged, or damaged shrouding or engine fins. Insufficient engine oil - Inspect oil level and replenish if necessary. Diesel Overload - Reduce diesel load. Fan belt is damaged. Change as required.

My dad uses Ford 6410 4WD. Yesterday he got a crunch in the rear axle. What problem tell me?

All signs talk about defect in the axle reducer.

Can someone say me what happened if engine white exhaust smoke?

If white smoke appeared from exhaust pipe you must to replace piston rings urgently. Worn cylinder liner and piston rings. Replace them with new ones.

FORD TRACTORS TROUBLESHOOTING
1710	1900	2120	2600	3600
3930	4100	4630	5600	5640
6410	6610	6640	6710	6810
7610	7740	7810	8210	8240
8630	8830	8770	TW30	TW35