________________________________________________________________________________

Ford 3600 Tractor Problems

The day before I noticed a malfunction on my Ford 3600 4x4. Diesel doesn't crank over. Tell me what is the problem?

You used an incorrect type of fuel. Malfunction of the fuel pump. Inspect and replace. Wrong fuel injection pump timing. Perform adjustment.

Farmtrac 3600 tractor damages. Low engine power. How can I troubleshoot it?

There is no full fuel feed due to misalignment of fuel pump control rods. Adjust control rods.

Help anybody why diesel engine stalling?

Dirt, water, or ice in fuel system. Jet nozzle clogged - Replace or repair the nozzle.

Ford 3600 tractor failure. Transmission rough shifting. What's the reason?

Shift fork, shafts lever, or detents worn loose - Tighten or replace.

Somebody help me why steering wheel turns very easy? What do I need to do to solve the problem?

Minimum Oil Rating - Top up the oil. The steering cylinder is heavily worn - Change the seal. Pump steering broke - Check the steering pump.

I purchased a Ford 3600 diesel tractor in april. Now there is trouble. Diesel engine not starting. Can anyone help me identify the source of malfunction?

Starter faulty - Need a replacement or overhaul. Restriction in a fuel pipe - Clean and flush. There is dirt in the fuel filter - Change it. Worn piston rings - Install new piston rings.

I use the same model. Recently, the steering turns in one direction. Help me find out what's malfunction?

Low oil index. Airlock in steering system. Remove air from system. Tire pressure uneven - Adjust it. Leak in hydraulic connections. Eliminate a damage. Power steering pump defect. Replace the pump. Power steering defective. Replace it.

3600 4WD tractor failure. Diesel engine hard to start. Need help to determine main cause of damage. What do I need to check?

Restriction in air filter/cleaner or induction system. Cold start system worked incorrectly. Broken or Worn Piston Rings. Injection pump drive shaft is defective. Water mixed in the fuel. Crankcase oil too heavy. Use oil of proper viscosity.

3600 tractor motor failures. Diesel long starting regularly. How can i fix malfunction?

Restricted Fuel Lines. Air leak on the suction side of the system. Clogging in exhaust pipe. Low voltage - Charge battery. Diesel injection nozzles faulty or sticking. Clogged fuel filter. Clean or replace fuel filter. Incorrect timing.

Steering doesn’t function on our tractor. How can I fix it?

The air was formed in hydraulic system. You should remove air. Minimum hydraulic oil level in the tank. Fill the tank. Problem with the hydraulic steering cylinder Change the seal.

I own the same model. Why engine failure to start? How could i fix malfunction?

Improper valve timing - Set a valve timing. High or Low compression. Cylinder bores wear - Need overhaul. Leakage between seats and valves - Eliminate leak.

Farmtrac 3600 tractor damages. Diesel knocks. what is the probable trouble?

Lack of oil. Fill up. Engine oil level low. Incorrect fuel - Fill with right fuel.

I can't figure it out why driving front axle to make a lot of noise chronically during operation?

Gears teeth crumbling. You need to install new gears. Roller bearings are very worn out. Fit new bearings.

I own this tractor about 5 years. Sometimes diesel engine start is difficult. How to eliminate?

Injection nozzle is clogged. You should to check a nozzle. The fuel pump has a breakdown. Replace fuel pump.

I get the same tractor. Can anybody tell me what's problem if differential lock broke down swiftly? How to solve the problem?

This is the diaphragm rupture or disks of the friction clutch are worn out. Requires repair.

Our company has Ford 3600 4WD diesel tractor. Diesel engine does not start. Help me how can I fix this?

Possibly Dirt in the fuel system. Otherwise the fuel pump to lost adjustments.

Please help. Diesel overheats regularly. What is the problem?

Lack of coolant in cooling system - Fill cooling system to proper level. Fan belt slipping - Adjust belt tension. Flywheel fins broken or damaged. Too much scale in the water jacket. De-scale the water jacket. Motor overloaded - Reduce motor load. Loose or defective fan belt - Replace fan belt as required. Check belt tensioner.

My father has Ford 3600 4x4. Yesterday he heard a crash in the rear axle. What's wrong?

All signs talk about bearing problems.

Can someone say me what is fault if motor exhaust with white smoke?

If white smoke comes from exhaust pipe you necessary to change piston rings urgently. Clogged air cleaner - Clean or replace elements.

FORD TRACTORS TROUBLESHOOTING
1710	1900	2120	2600	3600
3930	4100	4630	5600	5640
6410	6610	6640	6710	6810
7610	7740	7810	8210	8240
8630	8830	8770	TW30	TW35