________________________________________________________________________________

Ford 3415 Tractor Problems

The day before I discovered a malfunction on my 3415 tractor. Diesel engine will not crank. Tell me what kind of trouble?

Fuel type is wrong. The fuel pump drive is faulty. Inspect and refit. Wrong fuel injection pump timing. Adjustment required.

Ford 3415 damages. Engine has low power or compression. How to fix an issue?

Dirty/clogged muffler. Clean/replace muffler. Fuel supply pump, engine control common rail relief valve faulty. Excessive engine load.

Can someone say me why engine stalling?

Water separator clogged - Clean water separator.

3415 tractor question. Transmission shifts hard. What's fault?

Synchronizer worn, damaged, or improperly assembled - Replace or reassemble synchronizer.

Here is my question - why my steering wheel turns around too easy? What do I need to do for troubleshooting?

Low hydraulic oil level in tank - It is required to top up the oil. Steering cylinder has a defect - Perform repair. The steering pump is defective - Check the steering pump.

I acquired a Ford 3415 in march. Presently there is problem. Motor not starting. Can somebody help me diagnose the source of problem?

Starter faulty - Check starter and replace if necessary. Fuel line is clogged up - Wash and clean the fuel line. The fuel filter element is dirty - Replace it. Worn piston rings - Replace the piston rings.

I bought the same model. Recently, steering wheel turns bad. Tell me what are possible malfunctions?

Low Oil Rating. Top up the oil. Breakage of hydraulic hoses. It is necessary to fix a defect. Steering pump is defective. Replace the pump. Wear of power steering. Install the new power steering.

3415 tractor issue. Diesel very hard starting. Need help to identify prime cause of trouble. What needs to be repaired?

Fuel pump is not adjusted properly or dirty. Fuel shut-off valve closed. Cold start system worked incorrectly. Wear or deformation of piston rings. Valve Leakage/Adjustment Bad. Water in fuel. Fuel too heavy at low temperature.

Ford 3415 motor troubles. Diesel motor long starting sometimes. How could i fix a failure?

Restriction in fuel tank vent. Air leakage to the fuel inlet. Clogging in exhaust pipe. Slow starter speed. Diesel injection nozzles faulty or sticking. Filter clogged. Long Idle periods.

Steering stopped working on my tractor. How can I fix it?

The hydraulic system has air. You need draw out air. Hydraulic oil small indicator in system. It is required to add oil. Steering hydraulic cylinder worn out Repair it.

I use the same model. Why motor failure to start? How do i resolve the question?

Incorrect valve timing - Set a valve timing. Bad cylinder compression. Cylinder bores wear - Need overhaul. Leaks between seats and valves - Need Removal of leakage.

3415 tractor troubles. Diesel engine knocks. what is the probable damage?

Lack of oil. You should pour this. Engine oil level low. Incorrect fuel - Fill with right fuel.

Please help to understand why driving front axle to howls chronically during operation?

This is the failure of any gear. Replace gears. Bearings crumbled. Swap the replacement.

I have this tractor three years. Regularly diesel start is very hard. What a breakdown?

Nozzle is clogged. You must to inspect a nozzle. The fuel pump problems. Repair injection pump.

I bought the exact same tractor. Answer my question what reason if locking differential is defective swiftly? What's solution to the problem?

Diaphragm worn out or replace friction clutch discs. Replace parts.

I have Ford 3415. Motor doesn’t want to work. I need to know what's issue?

We can assume this is a clogged fuel filter. Or injection pump adjustment is not correct.

Need help. Motor overheating occurs. How can I fix it?

Lack of coolant in cooling system - Fill cooling system to proper level. Coolant level is less - Check level and leakage of system and top up. Cylinder head gasket is blown. Replace it with a new one. Engine overloaded - Reduce engine load. Broken or misadjusted fan belt - Adjust or replace.

My brother has 3415 tractor. Day before yesterday he heard a crash in the rear axle housing. What's wrong?

These symptoms evidence of bearing problems.

Can someone say me what is defect if diesel emits white smoke?

If white smoke comes out of exhaust pipe you necessary to change piston rings urgently. Injector pump or injectors delivering fuel unevenly. Check and service injectors and injector pump – specialist operation.

FORD TRACTORS TROUBLESHOOTING
1710	1900	2120	2600	3600
3930	4100	4630	5600	5640
6410	6610	6640	6710	6810
7610	7740	7810	8210	8240
8630	8830	8770	TW30	TW35