________________________________________________________________________________

Ford 5610 Tractor Problems

Lately I found out a breakdown with my Ford 5610 series 2. Diesel engine can not crank. Tell me what is the probable malfunction?

You must use the recommended fuel grade. Malfunction of the fuel pump. Check and overhaul. Incorrect fuel pump timing. Adjust if necessary.

5610 4WD tractor troubles. The engine fails to develop the full power. How should I get rid of problem?

Dirty/clogged muffler. Clean/replace muffler. Fuel supply pump, engine control common rail relief valve faulty. Excessive engine load.

Tell me what is the reason that irregular diesel engine running?

Water separator clogged - Clean water separator.

Ford 5610 question. Transmission rough shifting. What's fault?

Wrong transmission lubricant - Drain and fill with recommended lubricant.

Please tell me why my steering wheel turns very easy? What do I need to do to troubleshoot?

Low oil index - Fill the tank. Steering cylinder has damage - Perform repair. Defect in the power steering pump - Repair pump.

I acquired a Ford 5610 4x4 in april. Presently there is breakdown. Diesel won't start. Can somebody help me diagnose the source of issue?

Starter failure - Change or restore. Dirt in the fuel system - Wash and clean the fuel line. Fuel filter is dirty - Replace it. Piston rings are damaged - Must be repaired.

I use the same tractor. Recently, the steering stopped working. Somebody tell me what are possible malfunctions?

Low hydraulic oil level in tank. Power steering oil low. Refill oil to the required level. Steering shaft and sector gear stuck - Replace it. Leak in hydraulic connections. It is necessary to fix a fault. Steering pump is defective. Repair the pump. Wear of power steering. Diagnose the power steering.

5610 tractor issue. Diesel engine hard to start. Need help to find prime cause of breakdown. What should I do?

Air filter element restricted. Air lock in fuel line. Restricted fuel tank vent. Stale fuel. Cold start system used incorrectly. Piston rings are worn or broken. Cracked injector Body or Cup. Water mixed in the fuel. Fuel too heavy at low temperature.

Ford 5610 engine issues. Engine long starting regularly. How can i fix the breakdown?

Restricted Fuel Lines. Air leakage to the fuel inlet. Clogging in exhaust pipe. Low voltage - Charge battery. Dirty or faulty injectors. Filter clogged. Long Idle periods.

Steering does not operate on our tractor. What repairs should I do?

The hydraulic system has air. We recommend you release air from system. Low oil rate in the tank. Top up the oil. Steering hydraulic cylinder worn out Change the seal.

I am working on the same tractor. Why diesel motor does not start? How do i fix it?

Improper valve timing - Need setting of valve timing. Low compression. Cylinder bores wear - Need overhaul. Leakage between seats and valves - Eliminate leak.

5610 4x4 tractor issues. Diesel engine knocks. what is the trouble?

Lack of oil. Fill up. This is the low temperature of the coolant.

I can't find the reason why front axle to howls constantly at the moment of motion?

This is the failure of any gear. You must change the gears. Bearings have damage. You need to change it.

I own this model less than five years. Sometimes diesel starting is very difficult. What you need to fix?

Injector has clog. It is required to diagnose a nozzle. The fuel pump has a malfunction. Replace high-pressure fuel pump.

I get the same tractor. Can anybody tell me what's problem if locking differential can break immediately? What's solution to the problem?

Diaphragm worn out or wear of discs friction clutch. Replace parts.

We have Ford 5610 series 2. Diesel engine does not start. Tell me can i fix the problem?

Possibly fuel filter clogged. Or the fuel pump to lost adjustments.

Please help me. Engine constantly overheats. What kind of malfunction?

Lack of coolant - Refill with coolant. Loosened or damaged fan belt - Adjust the tension of belt or replace the belt with new one. Piston ring blow past. Replace with new rings. Engine overloaded - Reduce engine load. Broken or misadjusted fan belt - Adjust or replace.

My dad uses Ford 5610 4WD. Yesterday he diagnosed a crash in the rear axle. What is the malfunction?

These symptoms point to bearing problems.

Can someone say me what is defect if diesel engine exhaust white gas?

If white gas appeared from the exhaust pipe you necessary to replace piston rings urgently. Excessive engine oil - Reduce to specified level.

FORD TRACTORS TROUBLESHOOTING
1710	1900	2120	2600	3600
3930	4100	4630	5600	5640
6410	6610	6640	6710	6810
7610	7740	7810	8210	8240
8630	8830	8770	TW30	TW35