________________________________________________________________________________

Ford 7700 Tractor Troubleshooting

Two days ago I found out some problem with my Ford 7700 turbo. Motor can not crank over. Tell me what could be the trouble?

Fuel grade is wrong. Malfunction of the fuel pump. Diagnose and change. Incorrect fuel injection pump timing. Adjust if necessary.

7700 4x4 tractor damages. Engine low on power. How can I troubleshoot it?

The third ring is fitted upside down. Refit it, with the ring face marked (up) upward. Worn cylinder bore.

Help with the question what happened if diesel engine stalls?

Bearing bush burning-out. Check and replace it. Fuel line or fuel filter plugged.

Ford 7700 4WD tractor problem. Transmission shifts hard in reverse. What happened?

Clutch pedal not fully depressed. Loose shifter housing bolts.

Please tell me why steering wheel spinning too easy? What are my actions to get rid of problem?

Low Oil Rating - Pour completely. The steering cylinder is heavily worn - Change the seal. Steering pump have worn - Replace pump.

I acquired a Ford 7700 V8 in february. Presently there is malfunction. Diesel motor will not start. Could anyone help me define the cause of problem?

Starter does not work - Change or restore. Dirt in the fuel system - Clean and flush. Filter element is dirty - Renstall filter element. Wear piston rings - Install new piston rings.

I use the same tractor. Recently I noticed steering does not work well. Explain to me what is a breakdown?

Low oil index. Defective steering units pump. Improper toe-in. The front wheels are not aligned correctly. Oil flows out of the system. Eliminate a damage. Steering pump is defective. Replace the pump. Power steering defect. Diagnose the power steering.

7700 4WD tractor trouble. Motor is hard to start. Help me define the source of breakdown. What needs to be repaired?

Clogging in air filter/cleaner. Cold start system worked incorrectly. Piston rings are worn or broken. Defective fuel pump drive shaft. Water mixed in the fuel. Fuel too heavy at low temperature.

Ford 7700 motor failures. Diesel starts hard sometimes. How do i fix damage?

Clogging in fuel tank vent. Air leaks on intake hoses. Restriction in exhaust pipe. Slow starter speed. Injection fuel is little or the spray is not excellent. Clogged fuel filter. Clean or replace fuel filter. Incorrect timing.

Steering does not work on my tractor. Why did this happen?

The air was formed in hydraulic system. You need release air from system. Low oil rate in the tank. Pour completely. Problem with the hydraulic steering cylinder Repair it.

I own the same model. Why diesel motor has not been started? How do i fix a failure?

Valve timing is improper - Make adjustment. High or Low compression. Worn cylinder bores - Need overhaul. Leaks between seats and valves - Remove leakage.

7700 4x4 tractor problems. Diesel engine knocks. what is the probable trouble?

This is a small residue of engine oil. Fill with oil. Too much bearing play. Injection volume incorrectly set - Adjust settings.

Please help to understand why front axle produces a rumble chronically during operation?

This is gears damage. Replace gears. ball bearings crumbled. Replace it.

I own this model three years. Often engine start is intermittent. How to get rid of this?

Injector has dirt. You should to diagnose injector. The fuel pump is not working. Do overhaul of fuel pump.

I have the exact same model. Tell me why differential lock breaks down suddenly? What's solution to the problem?

The diaphragm torn or disks of the friction clutch are worn out. Requires repair.

Our company has Ford 7700 turbo. Motor does not start. Help me can I solve the problem myself?

Most likely fuel filter clogged. Otherwise the fuel pump not adjusted.

Need help. Diesel overheats regularly. How can I fix it?

Low coolant level - Fill coolant and check cooling system for loose connections or leak. Temperature thermostat is out of order, or insufficient coolant in tank. Check and replace the thermostat or replenish coolant. Diesel Overload - Reduce diesel load. Loose or problem fan belt. Adjust belt tension.

My dad uses Ford 7700 V8. Today he heard a noise in the crankcase of the drive axle. What is the malfunction?

These symptoms point to bearing problems.

Can someone say me what happened if diesel emits white smoke?

If white gas comes out of exhaust pipe you need to carry out replacement of piston rings urgently. Oil level too high - Reduce to correct quantity.

FORD TRACTORS TROUBLESHOOTING
1710	1900	2120	2600	3600
3930	4100	4630	5600	5640
6410	6610	6640	6710	6810
7610	7740	7810	8210	8240
8630	8830	8770	TW30	TW35