________________________________________________________________________________

New Holland 1630 Problems

A week ago I noticed trouble with my NH 1630. Diesel doesn't rotate. Tell me what is the probable damage?

You used an incorrect type of fuel. The injection pump is broken. Inspect and refit. Timing of fuel injection pump is incorrect. Adjustment required.

New Holland 1630 malfunctions. Poor engine output. How can I troubleshoot it?

There is no full fuel feed due to misalignment of fuel pump control rods. Adjust control rods.

Help anybody why engine stops during operation?

Insufficient fuel supply - Top up fuel and air-bleed fuel system. Wrong valve clearance.

1630 tractor question. Transmission rough shifting. What could it be?

Shifter forks, rods, or other transmission gear selection components damaged.

Somebody help me why steering wheel turns too easy? What do I need to do for troubleshooting?

Minimum Oil Rating - Pour completely. This is a steering cylinder malfunction - Change the seal. The steering pump is defective - Repair pump.

I purchased a New Holland 1630 in february. Presently there is breakdown. Diesel motor will not start. Could anybody help me determine the cause of issue?

Starter speed is slow - Check starter and replace if necessary. Fuel pipes are contaminated - Clean and wash. The fuel filter element is dirty - Replace fuel filter. Wear piston rings - Replace the piston rings.

I bought the same tractor. Yesterday I saw steering wheel operate hard. Tell me what's issue?

Low Oil Rating. Incorrect toe-in. Improper alignment of front wheels - Replace tie-rod. Hydraulic connections are not sealed. It is necessary to fix the problem. Steering pump is defective. Install the new pump. Power steering defective. Diagnose the power steering.

1630 tractor failure. Motor starts hard. Help me define the cause of issue. What needs to be repaired?

Dirty air filter. Clean/replace air filter. Dirty fuel filter. Replace fuel filter. Cold start system worked incorrectly. Damage or wear of piston rings. Gasket Blow-By or Leakage. Water in fuel. Crankcase oil too heavy. Use oil of proper viscosity.

New Holland 1630 diesel motor problems. Motor hard starting permanently. How could i fix the breakdown?

Restricted Fuel Lines. Air Leaks in Suction Lines. Exhaust pipe is clogged. Low voltage - Charge battery. Diesel injection nozzles faulty or sticking. Clogged fuel filter. Clean or replace fuel filter. Long Idle periods.

There was a malfunction of steering on our tractor. What repairs should I do?

Hydraulic system has a large amount of air. You need draw out air. Oil small indicator in the tank. Top up the oil. Wear of the hydraulic steering cylinder Change the seal.

I own the same tractor. Why diesel engine doesn't start? How can i fix the breakdown?

Valve timing is incorrect - Make adjustment. Compression increase. Wear cylinder bores - Need overhaul. Leaks between seats and valves - Remove leaks.

NH 1630 breakdowns. I hear the engine knocking. what is the issue?

Lack of oil. Add oil. Coolant temperature dropped.

I can not understand why tractor front axle produces a rumble incessantly at work?

Gears teeth crumbling. You must change the gears. Roller bearings are very worn out. Fit new bearings.

I own this tractor about 5 years. Recently, diesel engine start is very difficult. How to eliminate?

Injector has clog. You must to diagnose a nozzle. The fuel pump is damaged. Repair injection pump.

I get the exact same tractor. Explain to me why differential lock broke down abruptly? What's solution to the problem?

The diaphragm torn or wear of discs friction clutch. Change worn components.

We have a NH 1630. Engine doesn’t want to work. Help me can i fix the problem?

Probably fuel filter element has dirt. Or high-pressure fuel pump adjustment is not correct.

I have trouble. Motor overheats regularly. What is the fault?

Coolant level lowered. Pour liquid into radiator to recommended level. Clean the radiator from dirt and dust, if necessary, clean cooling system from scale. Adjust the fan belt tension. Detect the faulty injectors, wash, clean and adjust them. Excessive load - Reduce load or speed. Loose or fan belt issue - Adjust fan belt and replace if needed.

My dad uses 1630 tractor. Two days ago he diagnosed a crash in the crankcase of the drive axle. Which part is damaged?

All symptoms talk about bearing problems.

Can someone say me why diesel engine white exhaust smoke?

If white smoke comes from exhaust pipe you required to change piston rings immediately. Insufficient fuel delivery. Shortage of or faulty fuel.

________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________