________________________________________________________________________________

New Holland M160 Problems

Two days ago I recognized some issue on my NH M160. Diesel does not turn over. Explain me what is the failure?

You must use the recommended fuel grade. High-pressure fuel pump is damaged. Inspect and refit. Incorrect fuel pump timing. Perform adjustment.

New Holland M160 problems. Reduced performance of the engine. How should I solve the problem?

Burnt nozzle Have it repaired by the service representative. Engine’s moving parts seem to be seizing - Repair or replace.

Can someone say me what is damage if engine starts but stops after a short period of time?

Air in fuel system. Bleed air from system. Fuel tank vent restricted.

M160 tractor trouble. Transmission shifts hard in reverse. What could it be?

Worn or defective clutch - Replace worn parts.

Please give me information why my steering wheel turns around very easy? What are my actions to correct the situation?

Low Oil Rating - Pour full. Steering cylinder has damage - Change the seal. Steering pump have worn - Check the steering pump.

I acquired a NH M160 in april. Presently there is trouble. Engine not starting. Could anybody help me identify the cause of trouble?

Starter motor turns engine too slowly - Change or restore. Restriction in a fuel pipe - You should make washing and cleaning. Fuel filter is dirty - Change the filter. Piston ring failure - Install new piston rings.

I have the same tractor. Recently, steering wheel turns heavy. Can anybody tell me what is a breakdown?

Low oil index. Airlock in steering system. Remove air from system. Tire pressure uneven - Adjust it. Hydraulic connections are not sealed. It is necessary to eliminate the problem. Steering pump is defective. Replace the pump. Power steering is damaged. Install the new power steering.

M160 tractor question. Diesel motor starts hard. Need help to determine occasion of problem. What can I do?

Clogging in air filter/cleaner. Cold start system worked incorrectly. Defect or failure of piston rings. Valve Leakage/Adjustment Bad. Water in fuel. Fuel too heavy at low temperature.

New Holland M160 diesel motor malfunctions. Diesel starts hard permanently. How do i fix it?

Restriction in fuel tank vent. Air in fuel system. Restriction in exhaust pipe. Slow starter speed. Diesel injection nozzles faulty or sticking. Filter clogged. Incorrect timing.

There was a breakdown of the steering on our tractor. What's a breakdown?

The air is in hydraulic system. You need draw out air. Low oil rate in system. Pour completely. Problem with the hydraulic steering cylinder Change the seal.

I use the exact same model. Why engine failure to start? How do i resolve the question?

Valve timing is improper - Make adjustment. Low compression. Worn cylinder bores - Repair it. Leaks between valves and seats - Eliminate leakage.

New Holland M160 failures. Diesel engine knocks. what is the trouble?

Lack of oil. Fill with oil. Engine oil level low. Incorrect fuel - Fill with right fuel.

Please help to understand why driving front axle is cracking regularly during operation?

Teeth of gears collapsed. Replace gears. Bearings are firmly erased. You need to change it.

I own this tractor more than 3 years. Sometimes diesel start is difficult. What a breakdown?

Injection nozzle is dirty. You must to inspect injector. The fuel pump has a breakdown. Replace high-pressure fuel pump.

I get the exact same model. Can anybody tell me what reason if locking differential does not work swiftly? How to solve the problem?

Diaphragm worn out or disks of the friction clutch are worn out. Requires repair.

I'm using NH M160. Diesel engine not starting. Tell me what's issue?

We can assume fuel filter element has dirt. Or high-pressure fuel pump not adjusted.

Please help. Engine overheats regularly. How to fix the problem?

Low coolant level. Fill radiator to proper level, check radiator, coolant recovery tank, and hoses for loose connection or leaks. Engine air intake screen plugged. Engine gets overload - Decrease load or shift to low gear. Thermostat faulty - Replace. Excessive load - Reduce load or speed. Fan belt is damaged. Change as required.

My father has M160 tractor. Three days ago he diagnosed a crunch in the rear axle housing. What problem tell me?

All signs evidence of damaged bearings.

Tell me what is fault if motor exhaust with white smoke?

When white smoke comes from exhaust pipe you need to carry out replacement of piston rings immediately. Excessive engine oil - Reduce to specified level.

________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________