________________________________________________________________________________

Case IH 305 Magnum Problems - Repair tips

Yesterday I found out some issue with my Case IH 305 Magnum. Diesel motor will not crank. Tell me please what is the damage?

You must use the recommended fuel grade. Drive high pressure fuel pump is broken. Diagnose and change. Wrong fuel injection pump timing. Perform adjustment.

305 Case Magnum troubles. Insufficient engine power. How should I correct the situation?

Low compression - Have it repaired by the service representative. Poor atomization at nozzle. Service or replace it.

Can someone say me what is damage if engine runs unevenly?

Bearing bush burning-out. Check and replace it. Fuel line or fuel filter plugged.

Case 305 Magnum tractor question. Transmission rough shifting. What's fault?

Synchronizer worn, damaged, or improperly assembled - Replace or reassemble synchronizer.

I would like to know why steering wheel rotates not resisting? What do I need to do to troubleshoot?

Low hydraulic oil level in tank - Fill the tank. Steering cylinder has problems - Perform repair. Pump steering broke - Install a new pump.

I bought a Case IH 305 Magnum in november. Currently there is issue. Diesel motor will not start. Can anybody help me determine a source of breakdown?

Starter faulty - Change or refit. Restriction in a fuel pipe - You should make washing and cleaning. Fuel filter is dirty - Change the filter. Piston rings are damaged - Must be repaired.

I have the same model. Recently I noticed the steering turns in one direction. Somebody tell me what are possible malfunctions?

Low hydraulic oil level in tank. Airlock in steering system. Remove air from system. Tire pressure uneven - Adjust it. Leak in hydraulic connections. Eliminate a defect. Power steering pump defect. Replace the pump. Power steering has a defect. Replace it.

Magnum 305 tractor failure. Diesel engine very hard starting. Help me please identify the source of failure. What can I do?

Low compression. Oil pump worn or passages obstructed. Cold start system worked incorrectly. Piston rings are worn or broken. Cracked injector Body or Cup. Water in fuel. Fuel too heavy at low temperature.

Case 305 Magnum diesel motor malfunctions. Diesel motor is difficult to start permanently. How do i solve a problem?

Restricted Fuel Lines. Air leak on the suction side of the system. Exhaust pipe is clogged. Low voltage - Charge battery. Diesel injection nozzles faulty or sticking. Filter clogged. Long Idle periods.

Steering not working on my tractor. Why did this happen?

Hydraulic system has a large amount of air. We recommend you release air from system. The minimum hydraulic oil indicator in system. Top up the oil. Steering cylinder has a defect Repair it.

I own the same tractor. Why diesel does not start? How can i fix malfunction?

Valve timing is improper - Make adjustment. Compression increase. Wear cylinder bores - Repair it. Leakage between seats and valves - Eliminate leakage.

Magnum 305 issues. This is the engine knock. what could be the breakdown?

Oil of small quantity. Add oil. Coolant temperature dropped.

I have a problem why front axle to make a lot of noise continuously when tractor run?

This is the failure of any gear. You need to install new gears. ball bearings are very worn out. Fit new bearings.

I'm the owner this tractor about 4 years. Regularly diesel start is very difficult. How to get rid of this?

Nozzle has clog. Need to inspect a nozzle. High-pressure fuel pump has a malfunction. Repair injection pump.

I have the same model. Answer my question why differential lock is defective swiftly? How to solve the problem?

This is the diaphragm rupture or discs friction clutch worn out. You have to make repairs.

We have 305 Case Magnum. Motor not working. Tell me what is the fault?

Most likely fuel filter clogged. Or the fuel pump to lost adjustments.

I have the problem. Engine constantly overheats. What could be the problem?

Lack of coolant - Refill with coolant. Clogged radiator - Clean the core. Excessive load - Reduce load or speed. Loose or defective fan belt - Replace fan belt as required. Check belt tensioner.

My friend has Case IH 305 Magnum. Day before yesterday he heard knocking in the rear axle housing. Which part is damaged?

All symptoms point to bearing problems.

Can someone say me what is fault if engine emits white smoke?

If white gas comes out of exhaust pipe you required to change piston rings urgently. Cold-running engine - Allow to warm check thermostat.

CASE IH TRACTORS TROUBLESHOOTING
585	695	885	895	1494
1594	2096	2294	4230	5120
5130	5140	5220	5230	7110
7120	7220	7240	CS110	CVX130
CVX170	CX100	CX90	Farmall 75C	Farmall 95
Farmall 110A	Farmall 140A	JX100	JXU105	Magnum 250
Magnum 305	Maxxum 125	MX110	MX135	MX270