________________________________________________________________________________

Case IH 7220 Tractor Troubleshooting

The day before I got trouble on my International 7220. Diesel engine doesn't turn over. Tell me what is the probable failure?

Fuel type is wrong. The fuel pump drive is faulty. Inspect and replace. Incorrect fuel injection pump timing. Adjustment required.

Case IH 7220 issue. Reduced performance of the engine. How do I troubleshoot it?

Improper fuel. Insufficient compression or leaking valves. Operating temperature too low - Bring up to correct operating temperature.

Please explain me what is problem if engine stalling?

Air in the fuel lines or filter element blocked. Check, bleed air or replace the filter element.

7220 Magnum tractor trouble. Transmission shift hard at low speeds. What's the reason?

Linkage needs lubricant - Lubricate. Shift cover loose - Tighten cover.

Please tell me why my steering wheel turns too easy? What should I do to correct the situation?

Minimum Oil Rating - Pour full. Steering cylinder has a defect - Replace the defective part. Pump steering broke - Replace pump.

I acquired a Case 7220 in november. Currently there is damage. Diesel won't start. Could someone help me determine the cause of issue?

Starter turns bad - Inspect the starter and install a new as required. Clogging in the fuel line - You should make washing and cleaning. Dirty fuel filter element - Change the filter. Piston ring failure - Refit a new set of piston rings.

I bought the same tractor. Recently, the steering is very hard. Help me find out what is a breakdown?

Low oil index. Power steering oil low. Refill oil to the required level. Steering shaft and sector gear stuck - Replace it. Leak in hydraulic connections. It is necessary to fix a defect. Power steering pump defect. Check the steering pump. Hydraulic power steering is defective. Replace it.

7220 tractor issue. Motor cranks but not starting. Help me define occasion of breakdown. What needs to be repaired?

Broken choke or throttle cable. Choke adjusted incorrectly. Cold start system used incorrectly. Piston rings are wear or deformed. Valve Leakage/Adjustment Bad. Water mixed in the fuel. Crankcase oil too heavy. Use oil of proper viscosity.

Case IH 7220 diesel damages. Motor long starting sometimes. How can i fix malfunction?

Restriction in fuel tank vent. Air leaks on intake hoses. Exhaust pipe is clogged. Low voltage - Charge battery. Dirty or faulty injectors. Filter clogged. Long Idle periods.

Steering does not work on our tractor. What's a breakdown?

The air was formed in hydraulic system. You must release air from system. Low oil rate in system. Pour completely. Steering cylinder has problems Replace the faulty part.

I have the same tractor. Why diesel doesn't start? How can i fix a failure?

Wrong valve timing - Adjust valve timing. Bad compression. Worn cylinder bores - Need overhaul. Leaks between valves and seats - Remove leakage.

Case 7220 breakdowns. I hear a diesel knock. what kind of damage?

Oil of small quantity. Add oil. Engine overheated. Engine overloaded.

I have a problem why tractor front axle to make a lot of noise regularly when tractor run?

This is gears damage. You must change the gears. Bearings crumbled. Swap the replacement.

I'm the owner this tractor more than 3 years. Recently, diesel engine start is difficult. What you need to fix?

Nozzle has dirt. Need to inspect injector. Injection pump has a malfunction. Replace fuel pump.

I have the exact same tractor. Can anybody tell me why locking differential breaks down swiftly? What's solution to the problem?

Diaphragm worn out or discs friction clutch worn out. Replace parts.

We have a Case Magnum 7220. Diesel engine will not start. Help me what's issue?

Possibly fuel filter element has dirt. Otherwise high-pressure fuel pump adjustment is not correct.

Need help. Engine constantly overheats. How to fix the problem?

Coolant level lowered. Pour liquid into radiator to recommended level. Dirty radiator core, or grille screens. Remove all trash. Engine overloaded - Reduce engine load. Broken or misadjusted fan belt - Adjust or replace.

My friend has Case IH 7220. Yesterday he got knocking in the rear axle housing. What's wrong?

These symptoms denote damaged bearings.

Tell me what is fault if diesel excessive white smoke at idle?

If white smoke appeared from the exhaust pipe you need to carry out replacement of piston rings urgently. Excessive engine oil - Reduce to specified level.

CASE IH TRACTORS TROUBLESHOOTING
585	695	885	895	1494
1594	2096	2294	4230	5120
5130	5140	5220	5230	7110
7120	7220	7240	CS110	CVX130
CVX170	CX100	CX90	Farmall 75C	Farmall 95
Farmall 110A	Farmall 140A	JX100	JXU105	Magnum 250
Magnum 305	Maxxum 125	MX110	MX135	MX270