________________________________________________________________________________

Case JXU-105 Troubleshooting Issues

Yesterday I found out trouble with my Case IH JXU-105. Engine will not crank. Tell me please what kind of trouble?

Fuel type is wrong. High-pressure fuel pump is damaged. Inspect and refit. Wrong fuel injection pump timing. Adjust if needed.

Case JXU105 damages. Poor engine performance. How can I fix an issue?

The third ring is fitted upside down. Refit it, with the ring face marked (up) upward. Worn cylinder bore.

Help with the question why diesel engine misses?

Water separator clogged - Clean water separator.

JXU 105 tractor question. Transmission shifts hard in reverse. What happened?

Transmission misaligned - Correct alignment.

I would like to know why my steering wheel spinning very easy? What should I do to fix an issue?

The minimum oil level - It is required to add oil. Steering cylinder has problems - Replace the defective part. Pump steering broke - Repair pump.

I purchased a Case JXU-105 in november. Presently there is damage. Diesel won't start. Could anyone help me find a source of issue?

Starter faulty - Replace or repair. Clogging in the fuel line - Wash and clean the fuel line. The fuel filter element is dirty - Replace fuel filter. Worn piston rings - Must be repaired.

I have the same model. Recently I noticed steering wheel works bad. Tell me what is a breakdown?

Low Oil Rating. Pour completely. hydraulic connection leaking. Eliminate a fault. Pump of power steering is broke. Install the new pump. Power steering is damaged. Requires repair.

JXU 105 tractor trouble. Diesel is hard to start. Need help to define prime cause of trouble. What should I do?

Loose or damaged wiring. Check all wiring. Weak or dead battery. Cold start system worked incorrectly. Broken or Worn Piston Rings. High pressure fuel pump drive shaft is broken. Water, dirt, or air in fuel system. Drain, flush, fill and bleed system. Fuel too heavy at low temperature.

Case JXU105 motor issues. Motor hard starting regularly. How can i fix damage?

Restricted Fuel Lines. Air leakage to the fuel inlet. Clogging in exhaust pipe. Slow starter speed. Diesel injection nozzles faulty or sticking. Filter clogged. Long Idle periods.

There was a malfunction of steering on my tractor. What is problem?

The hydraulic system has air. You must release air from system. Hydraulic oil low level in the tank. Pour completely. Steering cylinder has a defect Make a replacement.

I use the exact same tractor. Why engine does not start? How can i solve a problem?

Wrong valve timing - Adjust valve timing. Compression increase. Cylinder bores wear - You must fix it. Leaks between valves and seats - Need Removal of leakage.

JXU-105 issues. Diesel engine knocks. what is the damage?

Oil of small quantity. Fill with oil. Cooling temperature is minimum.

I can not understand why driving front axle to howls chronically during operation?

Teeth of gears broke. Replace gears. Roller bearings are very worn out. You need to change it.

I have this tractor three years. Sometimes diesel start is very hard. How to get rid of this?

Injection nozzle is clogged. It is required checking a nozzle. High-pressure fuel pump does not work. Repair fuel pump.

I bought the exact same tractor. Tell me what's problem if locking differential can break immediately? What's solution to the problem?

This is the diaphragm rupture or replace friction clutch discs. Change worn components.

Our company has a Case IH JXU-105. Engine does not start. Help me how can I fix this?

Most likely Dirt in the fuel system. Otherwise the fuel pump is improperly adjuste.

Please help me. Diesel constantly overheats. What kind of malfunction?

Low coolant level - Fill coolant and check cooling system for loose connections or leak. Water pump is broken or its drive belt is too loose, resulting in water overheating. Check and adjust. Water temp. Gauge not working - Check and faulty replace. Excessive load - Reduce load or speed. Loose or defective fan belt - Replace fan belt as required. Check belt tensioner.

My dad uses Case JXU-105. Two days ago he got knocking in the crankcase of the drive axle. What's wrong?

All sounds denote damaged bearings.

Help with the question what is fault if diesel white exhaust smoke?

When white gas comes out of the exhaust pipe you required to change piston rings immediately. Excessive engine oil - Reduce to specified level.

CASE IH TRACTORS TROUBLESHOOTING
585	695	885	895	1494
1594	2096	2294	4230	5120
5130	5140	5220	5230	7110
7120	7220	7240	CS110	CVX130
CVX170	CX100	CX90	Farmall 75C	Farmall 95
Farmall 110A	Farmall 140A	JX100	JXU105	Magnum 250
Magnum 305	Maxxum 125	MX110	MX135	MX270