________________________________________________________________________________

Case IH MXM-140 Problems and Solutions

A week ago I discovered some trouble on my Case MXM-140. Diesel motor doesn't crank. Tell me please what is the issue?

Fuel grade is wrong. The fuel pump drive is faulty. Diagnose and change. Incorrect fuel pump timing. Adjust as required.

Case IH MXM140 damages. Reduced performance of the engine. How to troubleshoot it?

Air cleaner element is clogged. Air filter contaminated - Clean air filter. Deficient nozzle injection - Repair or replace nozzle.

Help anybody why diesel engine stalls?

Governor, plunger or sliding disc sleeve seized. Check, repair or replace them.

MXM-140 tractor trouble. Transmission shifts hard. What's fault?

Front bearing retainer loose or cracked - Tighten or replace retainer.

I would like to know why steering wheel rotates without opposition? How do I act to get rid of problem?

Low oil index - Fill the tank. Steering cylinder has problems - Perform repair. Defect in the power steering pump - Check the steering pump.

I purchased a Case IH MXM-140 in march. Now there is breakdown. Diesel won't start. Can someone help me find a source of malfunction?

Starter motor turns engine too slowly - Need a replacement or overhaul. Restriction in a fuel pipe - You should make washing and cleaning. Dirty fuel filter element - Replace it. Piston rings are broken - Must be repaired.

I have the same tractor. Recently I noticed steering wheel is hard to turn. Explain to me what's malfunction?

Low hydraulic oil level in tank. Air bubbles in hydraulic system. Bleed air out of the system. Check the suction pipe and rectify any leakage. Leak in hydraulic connections. It is necessary to eliminate a fault. Steering pump is worn out. Repair the pump. Power steering defect. Replace it.

MXM140 tractor issue. Diesel engine starts hard. Help me find main cause of malfunction. What should I check?

Broken choke or throttle cable. Choke adjusted incorrectly. Incorrect functions of the cold start system. Broken or Worn Piston Rings. Cracked injector Body or Cup. Water in fuel. Crankcase oil too heavy. Use oil of proper viscosity.

Case MXM-140 motor damages. Motor long starting regularly. How can i fix this defect?

Restriction in fuel tank vent. Air Leaks in Suction Lines. Exhaust pipe is clogged. Low voltage - Charge battery. Injection fuel is little or the spray is not excellent. Filter clogged. Incorrect timing.

There was a malfunction of steering on my tractor. What's a breakdown?

Hydraulic system has a large amount of air. You need remove air. Low oil rate in the tank. Fill the tank. Wear of the hydraulic steering cylinder Repair it.

I own the same tractor. Why diesel motor has not been started? How could i fix a failure?

Valve timing is improper - Make adjustment. Bad compression. Worn cylinder bores - You must fix it. Leakage between seats and valves - Remove leakage.

Case IH MXM-140 damages. The engine knocks. what kind of malfunction?

Lack of oil. You should pour this. Engine oil level low. Incorrect fuel - Fill with right fuel.

I can't find the reason why front axle is cracking constantly at work?

Gears teeth crumbling. Replace gears. Roller bearings have damage. Swap the replacement.

I own this tractor about four years. Regularly engine start is intermittent. What you need to fix?

Injector has dirt. You should to diagnose a nozzle. Injection pump is not working. Requires replacement of injection pump.

I have the exact same tractor. Can someone explain to me what's problem if differential lock does not work suddenly? What's solution to the problem?

Diaphragm damaged or wear of discs friction clutch. Requires repair.

I'm using a Case MXM-140. Diesel engine does not start. Tell me what is the fault?

Most likely fuel filter clogged. Otherwise high-pressure fuel pump is improperly adjuste.

Please help me. Diesel overheats regularly. How can I repair it?

Lack of coolant in cooling system - Fill cooling system to proper level. Choked radiator fins - Clean it. Insufficient coolant - Top up coolant. Choking of cooling system - Clean the cooling system. Motor overloaded - Reduce motor load. Fan belt is damaged. Change as required.

My brother has Case IH MXM-140. Three days ago he heard a noise in the rear axle housing. What problem tell me?

These symptoms evidence of bearing problems.

Can someone say me what is the reason that engine exhaust with white smoke?

When white smoke visible from the exhaust pipe you need to replace piston rings urgently. Excessive engine oil - Reduce to specified level.

CASE IH TRACTORS TROUBLESHOOTING
585	695	885	895	1494
1594	2096	2294	4230	5120
5130	5140	5220	5230	7110
7120	7220	7240	CS110	CVX130
CVX170	CX100	CX90	Farmall 75C	Farmall 95
Farmall 110A	Farmall 140A	JX100	JXU105	Magnum 250
Magnum 305	Maxxum 125	MX110	MX135	MX270