________________________________________________________________________________

Case MXU 115 Tractor Problems

The other day I found out a failure with my Case IH MXU 115. Diesel motor will not rotate. Tell me please what could be the damage?

Fuel grade is incorrect. Fuel pump drive problems. Inspect and refit. Timing of fuel injection pump is incorrect. Perform adjustment.

MXU115 tractor troubles. The engine fails to develop the full power. How can I troubleshoot it?

Worn piston rings and valve guides. Replace them with new ones. Wrong fuel injection advance angle. Set the recommended injection advance angle.

Can someone say me what is defect if irregular diesel engine running?

Dirt, water, or ice in fuel system. Jet nozzle clogged - Replace or repair the nozzle.

Case MXU 115 tractor failure. Hard shifting transmission. What's the reason?

Shifter forks, rods, or other transmission gear selection components damaged.

Please give me information why steering wheel turns around without resistance? What do I need to do to correct the situation?

Low oil index - Fill the tank. This is a steering cylinder malfunction - Change the seal. The steering pump is defective - Repair pump.

I acquired a Case IH MXU115 in september. Nowadays there is problem. Engine won't start. Can someone help me identify the source of damage?

Starter faulty - Replace or repair. Fuel pipes are contaminated - Flush and clean the fuel pipe. Filter element is dirty - Replace it. Worn piston rings - Change piston rings.

I use the same tractor. Recently, steering wheel turns heavy. Explain to me what is problem?

Low hydraulic oil level in tank. Insufficient oil delivery from the hydraulic pump. Check the hydraulic pump suction line and filter. Fix as required. Breakage of hydraulic hoses. It is necessary to fix a fault. Steering pump is worn out. Check the steering pump. Power steering is damaged. Diagnose the power steering.

MXU-115 tractor failure. Motor very hard starting. Help me specify main cause of problem. What do I need to check?

Fuel inlet needle sticking to seat. Fuel pump dirty or out of adjustment. Cold start system worked incorrectly. Broken or Worn Piston Rings. Gasket Blow-By or Leakage. Water in fuel. Fuel too heavy at low temperature.

Case MXU 115 diesel malfunctions. Diesel hard starting regularly. How do i fix damage?

Restricted Fuel Lines. Air leaks on suction lines. Clogging in exhaust pipe. Low voltage - Charge battery. Dirty or faulty injectors. Filter clogged. Fuel shut-off valve closed. Open fuel shut-off valve.

There was a malfunction of steering on our tractor. Why did this happen?

The hydraulic system has air. You need draw out air. Oil low level in the tank. Top up the oil. Wear of the hydraulic steering cylinder Repair it.

I own the exact same model. Why motor doesn't start? How do i solve a problem?

Incorrect valve timing - Need setting of valve timing. Compression increase. Wear cylinder bores - You must fix it. Leakage between valves and seats - Remove leaks.

Case MXU 115 failures. This is a diesel motor knock. what is the damage?

Oil of small quantity. You should pour this. Coolant temperature dropped.

Please help to understand why driving front axle to rattle constantly at work?

Teeth of gears broke. It is recommended to replace the gear. ball bearings crumbled. Swap the replacement.

I'm the owner this tractor three years. Sometimes motor start is very difficult. What a breakdown?

Injection nozzle is dirty. You must to inspect a nozzle. High-pressure fuel pump has a breakdown. Requires replacement of fuel pump.

I have the exact same model. Explain to me what reason if locking differential is defective swiftly? How can I fix it? What should I do?

Diaphragm worn out or wear of discs friction clutch. You have to make repairs.

Our company has a Case IH MXU 115. Diesel engine does not start. I need to know what is problem?

Possibly fuel filter element has dirt. Or the fuel pump adjustment is not correct.

Please help. Diesel overheats regularly. How to repair it?

Low coolant level. Fill radiator to proper level, check radiator, coolant recovery tank, and hoses for loose connection or leaks. Clogged radiator fins - Clean the radiator fins. Internal wear limits out of specification. Injector timing is too advanced. Adjust as per specification. Diesel Overload - Reduce diesel load. Broken or misadjusted fan belt - Adjust or replace.

My father has Case IH MXU115. Day before yesterday he diagnosed a crash in the rear axle housing. What's wrong?

These signs point to damaged bearings.

Please explain me what is problem if engine white exhaust smoke?

When white smoke comes from exhaust pipe you necessary to replace piston rings immediately. Cold-running engine - Allow to warm check thermostat.

CASE IH TRACTORS TROUBLESHOOTING
585	695	885	895	1494
1594	2096	2294	4230	5120
5130	5140	5220	5230	7110
7120	7220	7240	CS110	CVX130
CVX170	CX100	CX90	Farmall 75C	Farmall 95
Farmall 110A	Farmall 140A	JX100	JXU105	Magnum 250
Magnum 305	Maxxum 125	MX110	MX135	MX270