________________________________________________________________________________

Case IH Puma 165 Problems - Troubleshooting Tips

The day before I got trouble with my Case IH Puma 165 CVX. Diesel does not crank over. Tell me what is the probable malfunction?

Wrong type or grade of fuel used. Broken drive on fuel injection pump. Inspect and refit. Wrong fuel injection pump timing. Adjust if needed.

Case Puma165 problems. Poor engine output. How do I correct the situation?

Compression leak - Replace head gasket, tighten cylinder head screw, glow plug and nozzle holder. Engine not broken-in.

Tell me what is fault if engine runs unevenly?

Water separator clogged - Clean water separator.

Case Puma 165 problems. Transmission shifts hard in reverse. What's the reason?

Excessive clutch pedal free travel - Adjust free travel.

I would like to know why my steering wheel spinning too easy? What should I do to correct the situation?

Low Oil Rating - It is required to top up the oil. The steering cylinder is heavily worn - Perform repair. Defect in the power steering pump - Repair pump.

I acquired a Case IH Puma 165 CVX in september. Presently there is malfunction. Diesel not starting. Can anybody help me determine the cause of problem?

Starter rotates slowly - Diagnose starter and reinstall if necessary. Dirt in the fuel system - Clean and flush. Filter element is dirty - Change it. Piston rings worn out - You need repair.

I bought the same tractor. Yesterday I saw steering wheel operate bad. Explain to me what's malfunction?

Low hydraulic oil level in tank. Fill the tank. Breakage of hydraulic hoses. Eliminate a fault. Power steering pump defect. Check the steering pump. Power steering is damaged. Diagnose the power steering.

Puma 165 tractor problems. Diesel engine very hard starting. Help me identify prime cause of breakdown. What should I do?

Restriction in air filter/cleaner or induction system. Cold start system worked incorrectly. Broken or Worn Piston Rings. Cracked injector Body or Cup. Water mixed in the fuel. Crankcase oil too heavy. Use oil of proper viscosity.

Case Puma165 diesel motor damages. Diesel hard starting sometimes. How can i fix a failure?

Clogging in fuel tank vent. Air Leaks in Suction Lines. Restriction in exhaust pipe. Low voltage - Charge battery. Dirty or faulty injectors. Filter clogged. Long Idle periods.

Steering does not operate on my tractor. What's a breakdown?

The air is in hydraulic system. You need draw out air. Oil small indicator in system. Pour completely. Steering cylinder has a defect Change the seal.

Having used the same model. Why motor has not been started? How can i fix malfunction?

Wrong valve timing - Make adjustment. High or Low compression. Cylinder bores wear - You must fix it. Leakage between valves and seats - Eliminate leakage.

Puma 165 troubles. Diesel knocks. what kind of failure?

Lack of oil. You should pour this. Engine overheated. Engine overloaded.

I can't figure it out why front axle to howls continuously at work?

Defective gear. You must change the gears. ball bearings are firmly erased. Fit new bearings.

I own this model about four years. Recently, engine start is difficult. What a breakdown?

Injection nozzle is clogged. Need checking injector. The fuel pump does not work. Requires replacement of injection pump.

I get the same model. Explain to me why differential lock assembly does not work immediately? How to solve the problem?

The diaphragm torn or discs friction clutch worn out. Change worn components.

We have a Case Puma165. Engine not starting. Tell me how can I fix this?

Most likely fuel filter element has dirt. Otherwise the fuel pump to lost adjustments.

Please help me. Engine overheating occurs. How to repair it?

Lack of coolant - Refill with coolant. Loosened or damaged fan belt - Adjust the tension of belt or replace the belt with new one. Piston ring blow past. Replace with new rings. Motor overloaded - Reduce motor load. Loose or defective fan belt - Replace fan belt as required. Check belt tensioner.

My father has Case IH Puma 165 CVX. Today he diagnosed a strange noise in the rear axle. What problem tell me?

All sounds talk about destruction of bearings.

Tell me what is problem if motor exhaust white gas?

If white gas comes out of exhaust pipe you must to change piston rings urgently. Cold-running engine - Allow to warm check thermostat.

CASE IH TRACTORS TROUBLESHOOTING
585	695	885	895	1494
1594	2096	2294	4230	5120
5130	5140	5220	5230	7110
7120	7220	7240	CS110	CVX130
CVX170	CX100	CX90	Farmall 75C	Farmall 95
Farmall 110A	Farmall 140A	JX100	JXU105	Magnum 250
Magnum 305	Maxxum 125	MX110	MX135	MX270