________________________________________________________________________________

JD 6100 - Troubleshooting Issues

Lately I noticed the problem on my John Deere 6100. Motor can not crank. Tell me what is the probable breakdown?

Fuel grade is wrong. Malfunction of the fuel pump. Diagnose and change. Incorrect fuel pump timing. Adjust if needed.

Here is my question - why steering wheel turns around too easy? What do I need to do to correct the situation?

The minimum oil level - Top up the oil. The steering cylinder is heavily worn - Make a replacement. Steering pump have worn - Repair pump.

I got a John Deere 6100 in april. Nowadays there is trouble. Diesel won't start. Can someone help me determine a source of breakdown?

Starter faulty - Replace or repair. Dirt in the fuel system - Clean and wash. Fuel filter is dirty - Install new filter. Piston rings worn out - Refit a new set of piston rings.

I bought the same model. Yesterday I saw steering wheel operate hard. Explain to me what's issue?

Minimum Oil Rating. Pour completely. Hydraulic connections are not sealed. Eliminate the problem. Steering pump is worn out. Check the steering pump. Power steering defect. Requires repair.

6100 tractor issue. Diesel very hard starting. Need help to find the reason of malfunction. What should I check?

Clogging in air filter/cleaner. Cold start system worked incorrectly. Damage or wear of piston rings. Broken Fuel Pump Drive Shaft. Water in fuel. Crankcase oil too heavy. Use oil of proper viscosity.

JD 6100 diesel motor problems. Diesel engine hard starting regularly. How can i fix damage?

Restricted Fuel Lines. Air leaks on intake hoses. Clogging in exhaust pipe. Low voltage - Charge battery. Dirty or faulty injectors. Filter clogged. Long Idle periods.

There was a breakdown of the steering on my tractor. How can I fix it?

The hydraulic system has air. We recommend you draw out air. Small level of oil in the tank. It is required to add oil. Possible malfunction of hydraulic steering cylinder Repair it.

I own the exact same tractor. Why diesel failure to start? How can i resolve the question?

Valve timing is wrong - Set a valve timing. Compression increase. Wear cylinder bores - Need overhaul. Leakage between seats and valves - Remove leaks.

JD 6100 damages. This is a diesel motor knock. what is the probable breakdown?

This is a small residue of engine oil. Add oil. This is the low temperature of the coolant.

I can not understand why driving front axle to make a lot of noise regularly when driving?

Defective gear. Replace gears. Bearings have damage. You need to change it.

I have this model three years. Regularly motor start is intermittent. How to eliminate?

Injection nozzle is dirty. You must to diagnose injector. The fuel pump is not working. Repair fuel pump.

I get the exact same model. Explain to me what's problem if locking differential is damaged swiftly? How to solve the problem?

Diaphragm worn out or discs friction clutch worn out. Change worn components.

We have a John Deere 6100. Diesel engine not starting. Tell me how can I fix this?

Most likely fuel filter clogged. Otherwise injection pump adjustment is not correct.

Please help me. Motor overheating occurs. How to fix it?

Lack of coolant - Refill with coolant. Radiator is dirty - Clean it. Engine overloaded. Shift to lower gear or reduce load. Broken or misadjusted fan belt - Adjust or replace.

My dad uses 6100 tractor. Two days ago he got a crunch in the rear axle housing. Which part is damaged?

These signs evidence of bearing problems.

Can someone say me what happened if motor excessive white smoke at idle?

If white smoke comes out of the exhaust pipe you need to change piston rings immediately.