________________________________________________________________________________
Massey Ferguson 240 Problems
The other day I noticed trouble on my Massey Ferguson 240. Diesel
does not crank over. Tell me what kind of issue?
Fuel grade is wrong. The injection pump is broken. Diagnose and change.
Incorrect fuel pump timing. Adjust if needed.
MF 240 malfunctions. Engine has low power or compression. How do I fix
an issue?
There is no full fuel feed due to misalignment of fuel pump control
rods. Adjust control rods.
Help anybody what is the reason that diesel engine stalling?
Water separator clogged - Clean water separator.
Massey Ferguson 240 problem. Transmission shift hard at low speeds. What
could it be?
Excess amount of lubricant - Drain to level of filler plug.
Somebody help me why steering wheel turns around without resistance?
What do I need to do to correct the situation?
The minimum oil level - It is required to top up the oil. This is a
steering cylinder malfunction - Make a replacement. The steering pump is
defective - Replace pump.
I got a MF 240 in november. Today there is breakdown. Diesel will not
start. Could anyone help me define the cause of breakdown?
Starter failure - Change or restore. Fuel line is clogged up - Wash and
clean the fuel line. Dirty fuel filter element - Change the filter. Wear
piston rings - Refit a new set of piston rings.
I have the same model. Recently I noticed steering wheel stopped
turning. Can anybody tell me what's malfunction?
The minimum oil level. Faulty steering pump. Steering pump malfunction.
Tight ball joints. hydraulic connection leaking. It is necessary to
eliminate the problem. Steering pump is defective. Check the steering
pump. Power steering defect. Replace it.
240 tractor issue. Diesel is hard to start. Need help to recognize
occasion of malfunction. What do I need to check?
Fuel tank or fuel filter is clogged by dirt. Head gasket leaking. Cold
start system worked incorrectly. Defect or failure of piston rings.
Injection pump drive shaft is defective. Water mixed in the fuel. Fuel
too heavy at low temperature.
Massey Ferguson 240 diesel problems. Diesel is difficult to start
permanently. How can i resolve the question?
Clogging in fuel tank vent. Air in fuel system. Exhaust pipe is clogged.
Slow starter speed. Dirty or faulty injectors. Clogged fuel filter.
Clean or replace fuel filter. Long Idle periods.
Steering does not work on my tractor. What is problem?
The hydraulic system has air. You need remove air. Oil small indicator
in the tank. It is required to add oil. Problem with the hydraulic
steering cylinder Change the seal.
I own the same tractor. Why diesel doesn't start? How could i fix this
defect?
Improper valve timing - Make adjustment. Low compression. Wear cylinder
bores - Need overhaul. Leakage between seats and valves - Eliminate
leak.
240 tractor problems. This is a diesel knock. what is the probable
malfunction?
Lack of oil. You should pour this. Coolant temperature is low.
I can not understand why front axle produces a rumble continuously at
the moment of motion?
Defective gear. You need to install new gears. ball bearings have
damage. Fit new bearings.
I'm the owner this tractor more than 3 years. Sometimes motor start is
intermittent. What you need to fix?
Injection nozzle has dirt. It is required checking a nozzle. The fuel
pump does not work. Install a new fuel pump.
I have the same tractor. Answer my question why differential lock broke
down immediately? How to solve the problem?
Diaphragm damaged or disks of the friction clutch are worn out. You have
to make repairs.
I have MF 240. Diesel engine doesn’t want to work. Tell me what is
problem?
Possibly fuel filter element has dirt. Or high-pressure fuel pump not
adjusted.
I have the problem. Motor constantly overheats. How to fix it?
Lack of coolant in cooling system - Fill cooling system to proper level.
Radiator cap faulty - Replace with new one. Radiator core clogged -
Clean radiator core. Radiator screen clogged - Clean screen. Engine
overloaded. Shift to lower gear or reduce load. Fan belt is damaged.
Change as required.
My father has 240 tractor. Today he diagnosed a strange noise in the
crankcase of the drive axle. What problem tell me?
All sounds point to damaged bearings.
Tell me what is problem if motor exhaust with white smoke?
When white smoke comes from exhaust pipe you need to replace piston
rings immediately. Excessive engine oil - Reduce to specified level.
________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
MF TRACTORS SPECIFICATIONS |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
MF FRONT END LOADERS |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
MF TRACTORS MAINTENANCE |
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
MF TRACTORS TROUBLESHOOTING | ||||
1652 | 1749 | 2620 | 2725 | 2805 |
3050 | 3120 | 3640 | 3709 | 4245 |
4455 | 5320 | 5455 | 5613 | 6150 |
6280 | 6480 | 6615 | 7618 | 7720 |