Specifications, Service and Repair of Farm and Lawn Tractors

________________________________________________________________________________

John Deere LA110 Problems and Solutions

John Deere LA110 Engine Troubleshooting

Tractor engine starting problems

Fuel tank is empty - Fill gasoline up.
Wrong fuel grade - Change fuel.
Old gasoline - Drain fuel and add fresh.
Dirty fuel lines - Inspect and clean.
Defective spark plug wires - Install new spark plug wires.
Spark plug damaged - Change as required.
Clogged fuel filter - Change fuel filter.
Safety contact for brake pedal defective - Install new part.
Carburetor problems - Carburetor diagnostics required.
Test fuel transfer pump output. Check the Valves and Compression System.

Gas engine is difficult to start

Spark plug worn out - Inspect the spark, change if necessary.
Carburetor not adjusted - Adjust according to instructions.
Fuel pipes are clogged - Servicing fuel system.
Throttle cable is not adjusted correctly - Check and adjust.
Stale or improper gasoline - Pour quality fuel.
Electrical connection problems - Checking and replace.
Starter is not working - Test starter and repair if necessary.

Engine runs unevenly

Cooling fins plugged - Clean cooling fins.
Loose electrical contacts - Check and replace damaged connections.
Ignition adjust incorrect - Check ignition and adjust if necessary.
Choke cable sticking - Check and change if required.
Air filter blocked - Change air cleaner.

Engine runs but misses

Spark plug worn out - Change spark plug.
Carburetor is not adjusted correctly - Adjust carburetor as required.
Ignition coil air gap incorrect - Check and adjust ignition coil air gap.

JD LA110 Engine overheating

Engine runs under excessive load - Reduce loads.
Air inlet or cooling fins blocked - Clean clogged components.
Engine oil low or too high - Checking oil level and oil pressure.
Poor quality oil - Change oil.
Check connecting rod to crankshaft bearing clearance.
Idle speed problems - Adjust fast idle.

Engine doesn't idle speed

Spark plug is loose - Adjust spark plug gap.
Faulty spark plug - Inspect the spark, replace if necessary.

Engine knocking

Stale fuel - Change fuel.
Engine overload - Reduce the load.
Oil level low - Check oil level and add if necessary.
Engine speed too low - Adjust the required speed.
Piston rings and cylinder bore are wear - Inspect and replace if required.
Inspect for engine overheats from clogged cooling fins.
Check and adjust valve clearance.
Inspect for loose or wear connecting rods.

Engine back-fire

Check spark plug for fouled.
Inspect and adjust choke.
Adjust carburetor idle mixture screw.
Checking and adjusting ignition coil air gap.
Check inlet and outlet valves.
Checking and adjusting valve clearance.
Check flywheel key.

Insufficient engine power

Engine overheating - Replace air cleaner.
Excess engine oil - Excess oil must be drained.
Faulty fuel pump - Test fuel pump output.
Faulty governor - Inspect and adjust governor.
Inspect carburetor for plugged passages.
Test engine compression.

Excessive fuel consumption

Throttle did not open fully - Check choke cable.
Carburetor problems - Check carburetor float adjustment.

Black exhaust smoke

Air cleaner element plugged - Inspect and clean.
Throttle not fully engaged - Inspect and adjust choke.
Checking and adjusting carburetor float level.

JD LA110 Electrical System Troubleshooting

Starter does not run

Fuse is defective - Fit new fuse.
Battery contacts are corroded - Clean connections.
Battery not charged - Charge the battery.
Ignition switch defective - Install new switch.
Starter fault - Change the starter.
Electrical wires are damaged - Replace electric wires.

Battery doesn't charge

One or more battery cells dead - Install new battery.
Battery terminals and cables are dirty - Replace or clean cable.

Lighting does not function

Light plug defective.
Replace light bulbs.
Inspect electrical wires for short- circuit.

John Deere LA110 Machine Troubleshooting

Excessive tractor vibration

Equipment driven belt worn out - Belt replacement required.
Worn traction drive belt - Installing new driven belt.
Dirt on driven pulley - Clean the sheaves.
Bent cutting blade or no balance - Change damaged blades.

Engine runs but tractor won't move

Parking brake holds the tractor - Release the parking brake.
Bypass lever is on - Disengage the bypass valve lever.
Blade becomes loose - Fasten the blades securely.
Incorrect blade balance - Check blades for damage and balance as required.
Too much or too little oil - Topping up oil.

John Deere LA110 Lawn Mower Troubleshooting

Plugged discharge chute

Lawn mower is driving too fast - Need to reduce speed.
Grass too long - Use a shorter cutting height.
The grass is wet - Wait for the grass to dry.
Low engine speeds - Engine speed must be increased.
Loss of airflow - Adjust to high revs.
Low cutting height - Adjust cutting settings.
Incorrect belt installation - Check belt installation.

Patches of grass uncut

Cutting deck clogging - Clean mower deck.
Excessive blade wear - Check and replace the blade.
Mower deck is low from ground - Adjust and level the deck height.
Grass bag too full - Clean bagger.
Speed is very fast - Need to reduce speed.

Belt Slipping

Debris in sheaves - Recommend cleaning the sheaves.
Belt is worn out - Fit new belt.
Poor belt tension - Check and adjusting belt tension.

Too much mower vibration

Mower clogged or in pulleys - Clean sheave and deck from clogging.
Pulley or belt faulty - Replace damaged parts.
Pulleys or belt misaligned - Check and centering.
Improper blade balancing - Balance blades correctly.

Blades scalp grass

Incorrect height cutting - Raise cutting height.
Mower rollers not adjusted improperly - Adjust wheel heights correctly.
Insufficient tire pressure - Increase tire pressure.
Higher blade speed - Correct blades speed.
Blades are bent - Replace blades.

Uneven Cut

Mower deck not level - Level mower deck.
Tire pressure unequal - Tire pressure required.
Wrong rollers position - Check the rollers heights.
Speed too high - Operate the mower at low speed.
Mower blades blunt - Installing new blade.

________________________________________________________________________________

________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JOHN DEERE LAWN TRACTORS SPECIFICATIONS

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

ENGINES FOR JOHN DEERE LAWN TRACTORS

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JOHN DEERE TRACTORS ATTACHMENTS
420 430 455 790 990
X300 X320 X330 X350 X475
X485 X500 X540 X570 X590
X700 X720 X738 X758 1023E
2025R 2210 2520 3025E 3032E
3038E 3038R 3039R 3046R 3203
3320 3520 4052R 4066R 4100
4105 4115 4200 4310 4320
4400 4410 4520 4600 4720

________________________________________________________________________________________

JOHN DEERE FRONT END LOADERS

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JD TRACTORS TROUBLESHOOTING
2640 3040 3310 3650 4100
5050D 5090R 5410 6105R 7200R
E130 L111 LA110 LT155 X300R

________________________________________________________________________________________

JOHN DEERE FARM TRACTORS SPECIFICATIONS

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________