________________________________________________________________________________

John Deere LT150 Problem Solving

John Deere LT150 Engine Troubleshooting

Tractor engine not starting

Gas tank is empty - Fill fuel up.
Low-quality gasoline - Change gasoline.
Stale gasoline - Drain fuel and add fresh.
Dirty fuel lines - Inspect and clean.
Plug connection defective - Install new spark plug wires.
Spark plug not working - Installing new spark plug.
Fuel filter is plugged - Fuel filter needs changing.
Defective safety switch - Replace if required.
Carburetor malfunction - Check and repair as required.
Test fuel transfer pump output. Check the Valves and Compression System.

Engine is difficult to start

Spark plug failed - Test spark and change as required.
Carburetor settings incorrect - Adjusting as required.
Clogged fuel pipes - Clean the system carefully.
Worn throttle cable - Replace as required.
Stale or incorrect fuel - Pour quality fuel.
Electrical wiring worn out - Check and replace wires if necessary.
Starter is not working - Inspect the starter and change defective parts.

Engine runs roughly

Cooling fins are clogged - Clean cooling fins.
Loose electrical contacts - Check and repair defective connections.
Ignition system problems - Check ignition system and adjust as required.
Choke cable sticks - Repair or replace.
Air filter blocked - Replace air cleaner.

Engine misses under load

Spark plug worn out - Replace spark plug.
Carburetor is not adjusted correctly - Adjust carburetor as required.
Ignition coil air gap incorrect - Check and adjust ignition coil air gap.

Engine overheats

Excessive engine load - Reduce the load.
Air intake screen clogged - Clean dirty components.
Too much or too little oil - Inspect oil pump for damage or worn.
Improper engine oil viscosity - Change oil.
Inspect crankshaft to main bearing clearance.
Fast idle speed - Adjust fast idle.

Engine does not idle

Poor spark plug contact - Tighten the spark plug correctly.
Spark plug worn out - Check the spark and replace defective spark.

JD LT150 Engine knocks

Low octane fuel - Change fuel.
Engine overload - Reduce loads.
Oil level low - Add engine oil.
Engine speed too low - Adjust the required speed.
Cylinder bore or piston rings are damaged - Inspect cylinder bore or rings for worn.
Inspect for engine overheats from clogged cooling fins.
Inspect and adjusting crankshaft end play.
Check for worn crankshaft or camshaft bearings.

Engine back-fire

Inspect spark plug and change if required.
Adjust or replace throttle.
Checking and adjusting carburetor.
Checking and adjusting ignition coil air gap.
Inspect inlet and outlet valves.
Inspect and set valve clearance.
Checking flywheel key.

Engine lacks power

Engine temperature too high - Check air cleaner for plugged condition.
Too much oil in engine - Drain excess oil.
Fuel pump is damage - Repair or replace fuel pump.
Governor not work - Repair or replace governor.
Check and overhaul carburetor.
Test engine compression.

Engine uses too much fuel

Insufficient throttle opening - Replace choke cable.
Incorrect carburetor adjustment - Adjust carburetor.

Emits black smoke

Air filter element clogged - Check and clean.
Choke partially engaged - Inspecting and adjusting choke.
Check oil fill dipstick O-ring seal or cracked cap.

JD LT150 Electrical System Troubleshooting

Starter does not function

Main fuse defective - Check and change.
Battery terminals are corroded - Inspect and clean contacts.
Battery is discharged - Charge the battery.
Ignition switch is damaged - Change switch.
Damaged starter - Install new starter.
Electrical wires are damaged - Change wiring.

Battery doesn't charge

One or more battery cells dead - Change the battery.
Battery cables and terminals are dirty - Clean or change cable.

Lighting does not function

Headlight wire connector disconnected.
lamp does not work.
Wiring short circuit.

John Deere LT150 Machine Troubleshooting

Excessive tractor vibration

Implements drive belts damaged or worn - Inspect and change damaged belt.
Traction drive belt worn - Install new belt.
Drive sheaves malfunction - Replace if necessary.
Mower blades problem - Replace defective blades.

The engine is running but tractor is not moving

Parking brake holds the tractor - Disengage the park brake.
Bypass valve lever is engaged - Deactivate the bypass valve.
Blade becomes loose - Tighten mower blades.
Poor balancing after sharpening - Balance the mower blades correctly.
Lack of oil in transmission - Add transmission oil.

John Deere LT150 Lawn Mower Problems

Discharge Chute Plugged

Speed too high - Need to reduce speed.
Grass has grown too long - Adjusting cutting height.
The grass is wet - Do not mow when grass is wet.
Engine rpm reduced - Open choke wide.
Airflow restriction - Set higher revs.
Cutting too low - Change cutting height.
Belt is loose - Install the belt correctly.

Uncut grass during operation

Clog in discharge area - Inspect and clean cutting deck.
Defective blade - Installing new blade.
Mower deck low - Adjust and level the deck height.
Grass bagger overfilled - Clean grass bag.
Speed too high - Need to reduce speed.

Belt slips

Dirt in the sheaves - Need to clean the pulley.
Belt is loose - Check and change damaged belt.
No belt tension required - Check belt tension.

Excessive mower vibration

Mower deck clogged or in sheaves - Remove clogging from sheaves or mower deck.
Belt or sheaves faulty - Change damaged parts.
Pulleys or belt misaligned - Check and align.
Blades are not balanced correctly - Adjust blade balance.

Blade strips grass

Cutting too low - Set the proper cutting height.
Mower wheels not adjusted correctly - Check the wheel heights.
Low tire inflation - Tire pressure required.
Faster mower blade speeds - Balance mower speed.
Bent blades during operation - Replace blades.

Uneven cutting results

Deck level is too low - Level mower deck.
Tires inflated insufficient - Check and inflate the tires.
Rollers not positioned properly - Adjust mower deck wheels.
Speed too high - Use slower speed.
Mower blades dull - Inspect and fit new blade if required.

JOHN DEERE TRACTORS ATTACHMENTS
420	430	455	790	990
X300	X320	X330	X350	X475
X485	X500	X540	X570	X590
X700	X720	X738	X758	1023E
2025R	2210	2520	3025E	3032E
3038E	3038R	3039R	3046R	3203
3320	3520	4052R	4066R	4100
4105	4115	4200	4310	4320
4400	4410	4520	4600	4720

JD TRACTORS TROUBLESHOOTING
2640	3040	3310	3650	4100
5050D	5090R	5410	6105R	7200R
E130	L111	LA110	LT155	X300R