Specifications, Service and Repair of Farm and Lawn Tractors

________________________________________________________________________________

John Deere X534 Lawn Tractor Problems

John Deere X534 Engine Troubleshooting

Kawasaki engine will not start

Empty gas tank - Fill fuel up.
Low-quality gasoline - Use quality fuel.
Stale gasoline - Drain fuel and add fresh.
Dirty fuel system - Check and clean.
Defective spark plug wires - Check the spark plug wires.
Faulty spark plug - Check ignition spark.
Dirty fuel filter - Fuel filter needs changing.
Brake pedal not pushed down - Push the brake pedal down.
Carburetor problems - Carburetor diagnostics required.
Check and adjust governor linkage. Check the Valves and Compression System.

Gas engine long starting

Faulty spark plug - Test spark and replace as required.
Carburetor components worn out - Repair or replace parts.
Clogged fuel lines - Clean fuel system components.
Choke cable not adjusted properly - Checking and adjusting.
Old or improper fuel - Pour quality fuel.
Loose or corroded electrical connections - Inspect and replace.
Starter fault - Inspect the starter and change defective parts.

Engine runs roughly

Cooling fins are clogged - Remove dirt from cooling fins.
Loose electrical contacts - Inspect and repair defective contacts.
Incorrect ignition settings - Check ignition system and adjust as required.
Throttle cable sticks - Check and replace.
Air filter element clogged - Clean or replace the air filter.

Engine stops or misses

Spark plug wear - Replace spark plug.
Carburetor malfunction - Inspect and overhaul.
Ignition coil not working - Replace defective component.

Kawasaki engine overheating

Engine runs under excessive load - Reduce loads.
Air intake screen plugged - Clean clogged components.
Too much or too little oil - Add or drain oil.
Incorrect engine oil viscosity - Change engine oil.
Inspect crankshaft to main bearing clearance.
Too Fast idle - Adjust fast idle.

Engine will not idle

Poor spark plug contact - Check tightness of spark plug.
Spark plug failed - Check the spark and replace defective spark.

Engine knocks

Stale gasoline - Change fuel.
Excessive engine load - Reduce the load.
Low oil level - Add engine oil.
Engine is running at low revs - Adjust carburetor.
Piston rings and cylinder bore are wear - Replace defective components.
Check for engine overheating from plugged cooling fins.
Check and adjust crankshaft end play.
Check for carbon build-up in combustion chamber.

Engine backfires

Inspect spark plug and change if required.
Adjust or replace throttle.
Check and adjust carburetor.
Check and adjust ignition coil air gap.
Inspect inlet and outlet valves.
Check valve clearance, adjust if required.
Checking flywheel key.

Kawasaki engine lacks power

Engine overheats - Air cleaner element plugged.
Engine oil overfilled - Excess oil must be drained.
Fuel pump is damage - Inspect and repair fuel pump.
Defective governor - Inspect and adjust governor.
Check carburetor float adjustment.
Test engine compression.

Engine uses too much fuel

Insufficient choke opening - Adjust choke cable.
Incorrect carburetor adjustment - Check carburetor float adjustment.

Emits black smoke

Air filter element clogged - Check and clean.
Choke not fully engaged - Check and repair throttle.
Check and adjust carburetor float level.

John Deere X534 Electrical System Troubleshooting

Starter does not function

Blown main fuse - Install new fuse.
Poor terminal connection - Clean contacts.
Low battery voltage - Charge the battery.
Ignition lock defective - Replace switch.
Damaged starter - Install new starter.
Wires disconnected - Replace wiring.

Battery doesn't charge

One or more battery cells dead - Change the battery.
No contact between cable and battery terminal - Check and Clean.

Lights do not work

Light connector defective.
Check lamps.
Wiring damaged - Check and replace.

John Deere X534 Machine Troubleshooting

Tractor vibrates excessively

Attachment drive belts worn or damaged - Inspect and change damaged belt.
Worn traction drive belt - Check and replace belt.
Drive sheaves are dirty - Change if necessary.
The mower deck blades are bent or unbalanced - Change defective blades.

Machine does not move while engine is running

Parking brake is applied - Release the park brake.
Bypass valve lever in the push position - Set bypass valve to the off position.
Blades loose - Fasten the blades securely.
Poor blade balancing - Balance the mower blades correctly.
Low transmission oil - Topping up oil.

John Deere X534 Lawn Mower Problems

Clogged discharge chute

Traveling too fast - Choose recommended speed.
High grass - Adjust the mower to a lower cutting height.
Wet grass - Wait for the grass to dry.
Engine rpm too low - Open choke wide.
Loss of airflow - Adjust to high revs.
Mower cuts too low - Use higher cutting.
Belt fitted incorrectly - Reinstall the belt properly.

Uncut grass during operation

Debris in cutting deck - Inspect and clean cutting deck.
Defective blade - Check for blade damage and replace if necessary.
Mower deck low - Leveling the mower deck.
Grass bag overfilled - Clean bagger.
Traveling too fast - Need to reduce speed.

Belt slips

Debris in sheaves - Check and clean.
Drive belt damage - Check and change damaged belt.
Belt tension problems - Check and adjusting belt tension.

Excessive mower vibration

Debris in pulleys or in mower deck - Clean mower deck and sheave from debris.
Belt or sheaves faulty - Install new components.
Belt or pulleys out of alignment - Inspect and align.
Blades out of balance - Balance blades correctly.

Blade strips grass

Cutting too low - adjust cutting height.
Mower rollers height wrong - Adjust wheel heights correctly.
Low tire pressure - Inflate tires as required.
Blades speed too fast - Adjust the speed of blades.
Bent mower blades - Remove bent blade and fit new one.

Uneven cutting results

Deck too low - Adjust and level the deck height.
Tire pressure unequal - Increase tire pressure.
Incorrect rollers height - Check wheel adjustment.
Ground speed too fast - Use slower speed.
Mower blade worn or bent - Sharpen the blade or install a new one.

________________________________________________________________________________

________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JOHN DEERE LAWN TRACTORS SPECIFICATIONS

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

ENGINES FOR JOHN DEERE LAWN TRACTORS

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JOHN DEERE TRACTORS ATTACHMENTS
420 430 455 790 990
X300 X320 X330 X350 X475
X485 X500 X540 X570 X590
X700 X720 X738 X758 1023E
2025R 2210 2520 3025E 3032E
3038E 3038R 3039R 3046R 3203
3320 3520 4052R 4066R 4100
4105 4115 4200 4310 4320
4400 4410 4520 4600 4720

________________________________________________________________________________________

JOHN DEERE FRONT END LOADERS

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JD TRACTORS TROUBLESHOOTING
2640 3040 3310 3650 4100
5050D 5090R 5410 6105R 7200R
E130 L111 LA110 LT155 X300R

________________________________________________________________________________________

JOHN DEERE FARM TRACTORS SPECIFICATIONS

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________