________________________________________________________________________________

John Deere X750 Lawn Tractor Problems

John Deere X750 Diesel Engine Troubleshooting

Yanmar engine starting problems

Stale diesel fuel - Drain fuel and fill fresh up.
Fuel system clogged - Repair or replace.
Plugged fuel filter - Fuel filter needs to be replaced.
Faulty safety switch - Change damaged switch.
Fuel injector pump problems - Fuel pump diagnostics required.
Check starter cranking RPM. Test crankcase vacuum.

Engine starts hard

Fuel injection pump not adjusted - Adjust according to instructions.
Fuel pipes are clogged - Servicing fuel system.
Stale or incorrect fuel - Drain and add proper fuel.
Loose or corroded electrical connections - Check and replace.
Starter fault - Test starter and repair if necessary.

Rough running engine

Cooling fins blocked - Clean and wash cooling fins.
Loose electrical contacts - Check and repair damaged connections.
Dirty fuel injectors - Clean fuel injectors.
Air filter dirty - Replace air cleaner.

Yanmar diesel engine overheats

Excessive engine load - Reduce the load.
Air inlet or cooling fins blocked - Clean dirty components.
Engine oil low or too high - Checking oil level and oil pressure.
Incorrect engine oil viscosity - Change oil.
Check internal bearing clearance.
Idle speed problems - Adjust fast idle.

Engine knocks

Engine overloaded - Reduce loads.
Oil level low - Add to required level.
Low engine speed - Adjust carburetor.
Cylinder bore or piston rings are damaged - Check cylinder bore and rings for wear.
Check for engine overheating from plugged cooling fins.
Check and adjust crankshaft end play.
Inspect for loose or wear connecting rods.

Loss of power

Engine overheats - Air cleaner element plugged.
Engine oil overfilled - Remove excess oil.
Fuel injection pump is not working properly - Test fuel pump output.
Governor is damage - Inspect and repair governor.
Test engine compression.

John Deere X750 Electrical Troubleshooting

Starter doesn't work or will not turn engine

Main fuse defective - Installing new fuse.
Battery contacts are corroded - Clean connections.
Low charging voltage - Battery charging required.
Starter is not working - Change the starter.
Wires disconnected - Reconnect wires.

Battery does not charge

One or several cells defective - Fit new battery.
No contact between cable and battery terminal - Inspect and Clean.

Lighting does not function

Light connector defective.
Check light bulbs.
Check wiring for short circuit.

John Deere X750 Machine Troubleshooting

Excessive tractor vibration

Implements drive belts damaged or worn - Inspect and change damaged belt.
Traction drive belt worn - Installing new driven belt.
Dirt on driven pulley - Fit new pulley.
Mower blades malfunction - Balance the blades or replace.

Tractor will not move with engine running

Parking brake is applied - Unlock park brake.
Bypass valve lever in the push position - Disengage the bypass valve lever.
Loose lawnmower blades - Tighten mower blades.
Poor balancing after sharpening - Balance the blades correctly.
Lack of oil in transmission - Add oil to the transmission.

John Deere X750 Lawn Mower Problems

Discharge Chute Clogged

Speed too high - Choose recommended speed.
Grass has grown too long - try operating a short cutting height.
Wet grass - Do not use the mower if grass is wet.
Engine runs at low revs - Increase engine speed.
Lack of air flow - Check engine speed.
Mower cuts too low - Adjust to higher cutting.
Belt installed improperly - Fit belt correctly.

Streaking of uncut grass

Cutting deck clogging - Check cutting deck and clean if necessary.
Damaged or worn blade - Check and replace the blade.
Mower deck low - Level mower deck.
Bagger too full - Empty bagger.
Speed too high - Use slower speed.

Belt slips

Dirt in the sheaves - Need to clean the pulley.
Drive belt damage - Install new belt.
No belt tension required - Check and adjusting belt tension.

Excessive mower vibration

Mower clogged or in pulleys - Clean deck and pulley from debris.
Worn belt or pulley - Change worn components.
Misaligned belt or pulley - Check and centering.
Blades out of balance - Balance the blades.

Blades scalping grass

Wrong cutting height - adjust cutting height.
Mower height wheels not adjusted - Check wheel adjustment.
Tire pressure is uneven - Inflate tires as required.
High blade speed during mowing - Blade speed required.
Bent mower blades - Replace blades.

Uneven Cut

Mower deck low - Level mower deck.
Low tire pressure - Increase tire pressure.
Wrong rollers position - Check wheel adjustment.
Gear too fast - Don't use fast speed.
Mower blades blunt - Sharpen the blade or install a new one.

JOHN DEERE TRACTORS ATTACHMENTS
420	430	455	790	990
X300	X320	X330	X350	X475
X485	X500	X540	X570	X590
X700	X720	X738	X758	1023E
2025R	2210	2520	3025E	3032E
3038E	3038R	3039R	3046R	3203
3320	3520	4052R	4066R	4100
4105	4115	4200	4310	4320
4400	4410	4520	4600	4720

JD TRACTORS TROUBLESHOOTING
2640	3040	3310	3650	4100
5050D	5090R	5410	6105R	7200R
E130	L111	LA110	LT155	X300R